Section 2-1 - Care and Safety
Safety Notices
Safety Check List
2-1-14
2-1-14
9803/3750-05 (2-01-01)
!M
CAUTION
Do not disconnect the battery while the engine is
running, otherwise the electrical circuits may be
damaged.
INT-3-1-14
!M
WARNING
If you try to charge a frozen battery, or jump start and
run the engine, the battery could explode. Do not use
a battery if its electrolyte is frozen. To prevent the
battery electrolyte from freezing, keep the battery at
full charge.
0125
!M
WARNING
Battery Gases
Batteries give off explosive gases. Keep flames and
sparks away from the battery. Do not smoke close to
the battery. Make sure there is good ventilation in
closed areas where batteries are being used or
charged. Do not check the battery charge by shorting
the terminals with metal; use a hydrometer or
voltmeter.
INT-3-1-8
!M
DANGER
Electrolyte
Battery electrolyte is toxic and corrosive. Do not
breathe the gases given off by the battery. Keep the
electrolyte away from your clothes, skin, mouth and
eyes. Wear safety glasses.
INT-3-2-1_3
!M
WARNING
Battery Terminals
The machine is negatively earthed. Always connect
the negative pole of the battery to earth.
When connecting the battery, connect the earth (-)
lead last.
When disconnecting the battery, disconnect the earth
(-) lead first.
INT-3-1-9
!M
WARNING
Accumulators
The accumulators contain hydraulic fluid and gas at
high pressure. Prior to any work being carried out on
systems incorporating accumulators, the system
pressure must be exhausted by a JCB distributor, as
the sudden release of the hydraulic fluid or gas may
cause injury.
INT-3-1-17
!M
WARNING
Petrol
Do not use petrol in this machine. Do not mix petrol
with the diesel fuel; in storage tanks the petrol will rise
to the top and form flammable vapours.
INT-3-1-6
!M
WARNING
The cooling system is pressurised when the coolant is
hot. When you remove the cap, hot coolant can spray
out and burn you. Make sure that the engine is cool
before you work on the cooling system.
9-3-3-1_2
!M
WARNING
An exploding tyre can kill. Inflated tyres can explode if
over-heated or over-inflated. Follow the instructions
given when inflating the tyres. Do not cut or weld the
rims. Use a tyre/wheel specialist for all repair work.
2-3-2-7_2
!M
WARNING
Jacking
A machine can roll off jacks and crush you unless the
wheels have been blocked. Always block the wheels at
the opposite end of the machine that is to be jacked.
Do not work underneath a machine supported only by
jacks. Always support a jacked-up machine on axle
stands before working underneath it.
INT-3-2-8
!M
WARNING
Under no circumstances must the engine be run with
the transmission in gear and only one driving wheel
jacked clear of the ground, since the wheel on the
ground will move the machine.
INT-3-1-16
Summary of Contents for 535-125 Hi Viz
