jcb TM320, Operator'S Manual

Introduction

Safety Check List

15

15

9821-3100-6

!M

DANGER

Electrolyte

Battery electrolyte is toxic and corrosive. Do not
breathe the gases given off by the battery. Keep the
electrolyte away from your clothes, skin, mouth and
eyes. Wear safety glasses.

INT-3-2-1_3

!M

WARNING

Battery Terminals

The machine is negatively earthed. Always connect
the negative pole of the battery to earth.

When connecting the battery, connect the earth (-) lead
last.

When disconnecting the battery, disconnect the earth
(-) lead first.

INT-3-1-9

!M

WARNING

An exploding tyre can kill. Inflated tyres can explode if
over-heated or over-inflated. Follow the instructions
given when inflating the tyres. Do not cut or weld the
rims. Use a tyre/wheel specialist for all repair work.

2-3-2-7_2

!M

WARNING

Jacking

A machine can roll off jacks and crush you unless the
wheels have been blocked. Always block the wheels at
the opposite end of the machine that is to be jacked.
Do not work underneath a machine supported only by
jacks. Always support a jacked-up machine on axle
stands before working underneath it.

INT-3-2-8

!M

WARNING

Under no circumstances must the engine be run with
the transmission in gear and only one driving wheel
jacked clear of the ground, since the wheel on the
ground will move the machine.

INT-3-1-16

!M

WARNING

Wheels and tyres are heavy. Take care when lifting or
moving them.

Store with care to ensure that they cannot fall and
cause injury.

13-3-1-7_1

!M

CAUTION

Never use water or steam to clean inside the cab. The
use of water or steam could damage the on-board
computer and render the machine inoperable. Remove
dirt using a brush or damp cloth.

8-3-4-8

!M

WARNING

Asbestos

Asbestos dust can damage your lungs. Some engine
gaskets contain asbestos. Do not dismantle the
engine or exhaust system; get these jobs done by a
qualified person who has a copy of the engine service
manual.

5-1-6-1