P/N 960-000180R_Rev. 1 {EDP #233427}
© 2016, JAPAN CASH MACHINE CO., LTD.
6 - 5
Calibration and Testing
DBV® Series DBV-400 Banknote Validator
Section 6
Calibration
This section provides instructions for performing a
calibration of the DBV-400 Sensors.
When to Calibrate
Calibration should be performed when any of the
following conditions occur:
•
When removing one of the Circuit Boards;
•
When replacing one of the Circuit Boards;
•
When dirt adheres to the Sensors (See “Sensor and
Roller Cleaning Procedure” on page 2-11);
•
When the Banknote Acceptance Rate becomes
drastically degraded.
Placing the KS-095A Reference Paper
This section provides information regarding the
KS-095A Reference Paper’s settings and uses.
Perform the following steps to properly place the
KS-095A Calibration Reference Paper into the
DBV-400 Unit:
1. Press the Cash Box Release Button (Figure 6-23
a
) in the direction indicated by the blue arrow.
Then pull slightly upward and out in the direction
indicated by the red arrow
A
, and remove the
b
).
In the case of the optional Rear-Access Cash Box,
pressing the Cash Box Release Button (Figure 6-
a
) can be skipped.
Pull the Rear-Access Cash Box upward (Figure 6-
①
) to unlock the Box Latch and then out in
the direction Figure 6-24
②
.
2. Press the Validation Guide Open/Close Latch
a
) upward, then pull the Validation
b
) out of the DBV-400 Unit.
3. Remove Guide Chip A (Figure 6-26
a
) and Guide
Chip B (Figure 6-26
b
) from the DBV-400 Unit.
4. Insert the small end of the KS-095A Reference
a
) through the backside of the
DBV-400 Banknote Path. The small end will
come out of the Bezel’s Banknote Insertion Slot
b
).
NOTE: Refer to Figure 6-1 and Figure 6-2
for the necessary Tool and Harness
Connections and USB Cable Type
Requirements respectively.
NOTE: Do not bend the Holders (
a
) or touch the Paper Surfaces on either side
of the KS-095A Reference Paper (
b
).
Figure 6-22
Figure 6-22
KS-095A Reference Paper
b
a
Placing KS-095A Reference Paper
Figure 6-23
Placing KS-095A Reference Paper 1
(Standard Cash Box)
The Standard Cash Box has a blue-colored Cash Box
Release Button
Figure 6-24
Placing KS-095A Reference
Paper 1 (Rear-Access Cash
Figure 6-24
Placing KS-095A Reference Paper 1
(Rear-Access Cash Box)
a
The Rear-Access Cash Box has a black-colored Cash
Box Release Button
Figure 6-25
Figure 6-25
Placing KS-095A Reference Paper 2
a
b
Figure 6-26
Figure 6-26
Placing KS-095A Reference Paper 3
a
b
