KisanKraft
®
Agricultural Portable Sprayer (Power)
KK-P767/ P768/ P769/ P780, KK-TPS-60T
Agricultural Knapsack Sprayer (Power)
KK-707/ 708/X/AL, KK-KPS-162 / 802
This warranty is null & void, if you fail to register the warranty with
KisanKraft by
sending the KisanKraft Copy with dealer’s stamp.
: www.kisankraft.com
: info@kisankraft.com
: +91.80. 6835 7800
5.
While holding down the engine firmly,
grasp the recoil starter grip and pull
vigorously
CAUTION:
a)
When the engine stops on
the way after starting, or
b)
When the engine fails to start
after
trying
the
recoil
operation for 7 to 8 times.
Return the starter lever to the operating
position and try the recoil operation.
6.
If you move the throttle lever to the high-speed side a little after the engine has
started, the starter lever returns to the operating position. Continue the warm-
up operation for 2 to 3 minutes in this condition. Observing the condition of the
engine, move the throttle lever to a desired engine speed.
START
CAUTION
•
Before starting the engine, confirm that the area of radius 15 m around the engine
is completely evacuated.
•
Do not operate the engine when any flammable material (gasoline, volatile
chemicals, or others) is present around it.
•
Driven equipment may start simultaneously with the start of engine. Carefully
read the instruction manual of the equipment and start the engine carefully.
•
When a class FC oil is used, a larger resistance may be felt when pulling the
recoil starter grip under low temperature condition or at the initial operation at the
next season. This is related to the characteristic of the oil and there is no problem
on the engine. Once started, it will return to the normal condition
Concerning New Start System
It can start even if it is pulled slower than normal.
•
If the rope is pulled (vigorously) till it will not come out any more, it could damage
the recoil mechanism.
•
Do not disassemble the recoil.
It is dangerous to disassemble the inside of recoil. (Consult your dealer when it
is necessary to replace related parts.)
•
If the decompression slot of cylinder is clogged, the engine may start slower than
normal. Clean the slot to restore the normal condition.
STOP
KisanKraft
®
Agricultural Portable Sprayer (Power)
KK-P767/ P768/ P769/ P780, KK-TPS-60T
Agricultural Knapsack Sprayer (Power)
KK-707/ 708/X/AL, KK-KPS-162 / 802
: www.kisankraft.com
: info@kisankraft.com
: +91.80. 6835 7800
Page 15 of 48
Operation (
KK-P767/ P-768 / P769 /
P780
& KK-TPS- 60T
):
1.
Turn the handle of the control valve to
match the pressure of operating
conditions.
2.
Check spraying conditions and the
status of the equipment, and set the
throttle lever to the high speed
position.
3.
When the nozzle cock is opened, chemicals will be atomized as they come out of the
nozzle.
IMPORTANT
1.
After each 4 continuous working hours, please turn the cap of grease cup for 1 or 2
rounds. This will lubricate the piston and prolong its life.
2.
After every 100 working hours, please inspect the engine oil level in the pressure
pump(you can see it from the oil window of the pump).In case, the oil level is lower
than1/3 position, please remove the oil inlet bolt and add engine oil up to 2/3 position
3.
Be careful of the amount of fuel in the tank, and refill it when it becomes low.
To Stop:
Temporary halt during operation:
1.
Close the spray gun, and return the throttle lever to low speed.
2.
Press the engine stop button.
3.
After the engine stops, close the fuel cock.
Stopping the sprayer after completing spraying:
1.
Drain off all of the chemical from the chemical tank.
2.
Fill the chemical tank with clean water, operate the engine, and clean the pump and
hose interior by spraying the clean water.
