3
113019-
CA
(1093)
Kohler Co., Kohler WI
TABLE OF CONTENTS
IMPORTANT SAFETY INSTRUCTIONS
2
. . . . . . . .
INTRODUCTION
3
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
ROUGHING-IN: K-1353-AA, K-1354-AA
4
. . . . . . . .
Ordering Information
4
. . . . . . . . . . . . . . . . . . . . . . .
Required Electrical Service
4
. . . . . . . . . . . . . . . . . .
Product Information
4
. . . . . . . . . . . . . . . . . . . . . . . .
Installation Notes
4
. . . . . . . . . . . . . . . . . . . . . . . . . .
PRODUCT NOTICES
5
. . . . . . . . . . . . . . . . . . . . . . . . .
Installer Hazard Notification
5
. . . . . . . . . . . . . . . . .
Factory-Assembled Features
5
. . . . . . . . . . . . . . . .
PRODUCT REQUIREMENTS
5
. . . . . . . . . . . . . . . . .
Summary of Key Requirements
5
. . . . . . . . . . . . . .
Plumbing Specifications
5
. . . . . . . . . . . . . . . . . . . . .
Product Inspection
5
. . . . . . . . . . . . . . . . . . . . . . . . .
Electrical Requirements
5
. . . . . . . . . . . . . . . . . . . . .
INSTALLATION REQUIREMENTS
6
. . . . . . . . . . . . .
Tools Required
6
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Materials Required
6
. . . . . . . . . . . . . . . . . . . . . . . . .
Clearance Requirements
6
. . . . . . . . . . . . . . . . . . . .
New or Replacement Installation Requirements
6
SITE REQUIREMENTS
6
. . . . . . . . . . . . . . . . . . . . . . .
Old Bath Removal
6
. . . . . . . . . . . . . . . . . . . . . . . . . .
Subfloor Preparation
6
. . . . . . . . . . . . . . . . . . . . . . . .
Remove Aprons and Inspect Unit
7
. . . . . . . . . . . . .
Stud Pocket Preparation
7
. . . . . . . . . . . . . . . . . . . .
Plumbing Preparation
7
. . . . . . . . . . . . . . . . . . . . . . .
BEFORE INSTALLING UNIT
8
. . . . . . . . . . . . . . . . . .
Recommended Installation
8
. . . . . . . . . . . . . . . . . .
Partially Install Bath Drain
8
. . . . . . . . . . . . . . . . . . .
Protect Bath Unit
8
. . . . . . . . . . . . . . . . . . . . . . . . . . .
INSTALL BATH
9
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Bath Set-In
9
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
To Adjust Level
9
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Connect Drain
9
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Secure Bath
10
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
COMPONENT LOCATION
10
. . . . . . . . . . . . . . . . . . . .
FIELD WIRE COMPRESSOR
11
. . . . . . . . . . . . . . . . .
Service Requirements
11
. . . . . . . . . . . . . . . . . . . . . .
Identify Electrical Requirements
11
. . . . . . . . . . . . . .
Connect Control - 120 V, 60 Hz
11
. . . . . . . . . . . . . .
TEST DOOR SYSTEM
12
. . . . . . . . . . . . . . . . . . . . . . .
Operating Sequence
12
. . . . . . . . . . . . . . . . . . . . . . . .
Troubleshoot Door System
12
. . . . . . . . . . . . . . . . . .
INSTALL APRONS
13
. . . . . . . . . . . . . . . . . . . . . . . . . . .
INSTALL FINISH WALL
13
. . . . . . . . . . . . . . . . . . . . . . .
INSTALL KICK STRIP
14
. . . . . . . . . . . . . . . . . . . . . . . .
CLEAN-UP AFTER INSTALLATION
14
. . . . . . . . . . . .
INTRODUCTION
Please read these instructions carefully to familiarize
yourself with the required tools, materials, and
installation sequences. Follow the sections that pertain
to your particular installation. This will aid you in avoiding
the unnecessary expense associated with improper
installation. In addition to proper installation, read all
operating and safety instructions.
The variety of installations possible with this bath may
require framing procedures other than those described
in this manual.
All information in this manual is based on the latest
product information available at the time of publication.
Kohler Co. reserves the right to make changes in
product characteristics, packaging, or availability at any
time without notice.
Identify and record below the model and serial number:
Model No.
Serial No.
Date of Manufacture
