PERIODIC SERVICE
76
EVERY 1500 SERVICE HOURS
Perform inspection and servicing for every 50, 250 and
500 hours of operation at the same time.
B
Checking Injector Tip
Consult your local KUBOTA dealer for this service.
EVERY 2000 HOURS SERVICE
Perform inspection and servicing for every 50, 250, 500
and 1000 hours of operation at the same time.
B
Checking alternator and starter motor
After every 2000 hours of use, check and maintain the
alternator and starter motor. It is just about the time the
brushes would become worn.
It is recommended to have the test and overhaul done by
your KUBOTA dealer.
If the lights are often used during work, inspect the
alternator every 1000 hours.
EVERY 3000 SERVICE HOURS
Perform inspection and servicing for every 50, 250, 500,
1000 and 1500 hours of operation at the same time.
B
Checking Injection Pump
Consult your local KUBOTA dealer for this service.
ANNUAL SERVICE
B
Checking electrical leads and terminals
A
Check the good condition and firm fit of all accessible
electrical leads, connectors and terminals.
A
Repair or replace damaged parts.
A
Check fuse box and fuse holders for oxidation and
soiling and clean if necessary.
BIENNIAL SERVICE
Perform inspection and servicing for annual operation at
the same time.
B
Replacing fuel hoses and clamps
To avoid personal injury or death:
A
A broken fuel line will cause fuel to leak.
Be sure to check the line. Fire or injuries may
result if a fuel line is leaking.
A
Make sure the engine is cool before
disconnecting fuel lines.
Rubber parts like the fuel lines are likely to age even if the
engine is not used regularly. Therefore, it is necessary to
replace these parts with new ones once every two years
or sooner if they are damaged.
1. Regularly check that the lines and clamps are not
loose or damaged.
2. When the fuel line has been replaced, be sure to bleed
air from the line.
A
When replacing the fuel lines, take special care to
prevent dirt and other foreign matter from entering the
fuel system. Entry of foreign matter in the fuel system
will likely cause serious damage.
Summary of Contents for R065
