87
Any oil used in place of the KYMCO recommended en-
gine oil can cause serious engine damage.
GENERAL MAINTENANCE
5. Remove the oil filter cartridge
5
with a suitable oil filter
wrench. Rotate the oil filter cartridge counterclockwise to
remove it from the engine.
NOTE: Skip step 5 and proceed to step 7 if you are not
going to replace the oil filter cartridge.
6. Lubricate the new oil filter cartridge’s o-ring gasket with
clean engine oil and install the filter on the engine. Tighten
the oil filter cartridge by rotating it clockwise unit it se-
curely seats to the engine
7. Reinstall the oil strainer and its component parts. Tighten
the oil strainer cap securely
8. Reinstall the oil drain plug and tighten it securely
9. Add the appropriate amount of engine oil
5
5
5
5
5
OIL QUANTITY
Without oil filter........................ 3.18 US qt, (3.0 L)
With oil filter change ............... 3.82 US qt, (3.6 L)
NOTE: The UTV should be parked on level ground, with
the engine off, when checking the engine oil level. Wait
approximately one minute after running for the oil level
to stabilize before checking.
7
7
7
7
7
7
7
7
7
7
Do not overfill the engine with oil. Overfilling the engine
can cause oil leaks and/or oil contamination of the air
filter element. Always make sure the oil level is above
the "L" mark but not higher than the "H" mark.
10. Warm up the engine for several minutes, then turn it off
11. Check the oil level at the inspection window
12. The oil level in the window
6
should be above the "L"
mark, but not higher than the "H" mark. Add oil through
the filler cap
7
as required
NOTE: Dispose of the used oil and filter in an environmen-
tally appropriate way.
Summary of Contents for UXV500iG
