The FT Series Floor Standing, Combination Boiler
Page 15
DANGER
Vapors from flammable liquids can explode and
catch on fire, resulting in severe burns or death.
Do not use or store flammable products such
as gasoline, solvents or adhesives in the same
room or area near the appliance.
Keep flammable products
Far away from boiler
In approved containers
Tightly closed
Out of children’s reach
Vapors
Cannot be seen
Are heavier than air
Spread on the floor
Can spread from other rooms to the main burner
by air currents
Do not install the appliance where flammable
products will be stored.Read and follow boiler
warnings and instructions thoroughly. If owner’s
manual is missing, contact the retailer or
manufacturer.
This combination boiler must be installed by a
qualified plumber, a licensed gas fitter, and/or a
professional service technician.
Improper installation and/or operation will cause a
potentially hazardous situation, such as serious injury
or death. Also, it will void the warranty.
• The National Fuel Gas Code NFPA 54 / ANSI Z224.1
• National Electric Code ANSI/NEPA 70
• All applicable local, state, national and provincial
codes, regulations and laws.
Proper care is your responsibility. Carefully read and
understand the Operating Information in this manual
before operating the boiler.
Be aware of the location of the gas shut-off valve
and operation method. Close the gas shut-off valve
immediately if the appliance is subjected to fire,
overheating, flood, physical damage, or any other
damaging condition that might affect the operation
of the unit. Boiler must be checked by a qualified
technician before resuming operation.
DO NOT use this Boiler if any part has been under
water. Immediately call a qualified technician for
inspecting the Boiler and replacing any part of the
control system and gas control which have been under
water.
Do not power up the unit until the gas and water supply
valves are fully opened. Make sure that the fresh air
intake port and exhaust gas port are opened and
functional.
DO NOT attempt to install, repair, or service this Boiler
by yourself.
Do not change any part of the Boiler.
Contact a qualified technician if the Boiler needs repair
or maintenance.
Ask your gas supplier for a list of qualified service
providers.
DO NOT use spray paint, hair spray, or any other
flammable spray near Boiler or near the exterior fresh
air inlet port. DO NOT place any items in or around the
exterior exhaust gas outlet port and/or fresh air inlet
port. These could restrict or block the flow in or out of
the vent system.
“Caution: While repairing control, all wires are labeled.
You must connect the wires in accordance with the
instruction. Wiring errors can cause improper and
dangerous
operation.
“Verify proper operation after servicing operation”
This consists of the gas ignition system components
which are protected from water (dripping, spraying, rain,
etc.) during operation and service (circulator replacement,
condensate trap, control replacement, etc.).
After installing the heater, safety devices must be
tested.
This boiler is equipped with a blocked vent shutoff
system.
If the error code ‘41’ occurs, follow the instructions
below.
- First, turn off the manual gas valve.
- Make sure that there is no foreign object in the vent
passage or rodent screen.
- If you do not find any problem, do the following.
- Turn off the error state by pressing the power button
of control panel.
- If the error occurs repeatedly, call your service
technician or gas supplier.
