Operating the A
UTOMIZER
V
ERSA
H
AND
TM
69
2.
Make sure the tailgate is fully open.
3.
Make sure the air pressure is above 70
psi.
4.
Check all fuses in the console.
5.
Contact the maintenance facility if there is no change.
6.
If equipped with air suspension, it needs to be dropped.
7.
If equipped with a tag axle, it must be lowered.
Emergency Actions
Hydraulic Oil Spill
In case of hydraulic spill, do the following:
1.
Press the emergency red button.
2.
Turn off the pump switch and stop the truck engine.
3.
Close the main valve on the hydraulic tank.
4.
Carefully inspect and find the cause of the leak.
5.
Call the maintenance facility and report your findings.
6.
If the leak cannot be repaired on site, and the vehicle cannot be towed, remove the pump drive
shaft before restarting the engine.
7.
When it is time to restart the pump after repair, ensure that the valve on the hydraulic tank is fully
open and that there is sufficient oil in the hydraulic tank.
End-of-the-Day Cleaning and Inspection
Daily Hopper Cleaning
Cleanliness is a key part of safety and critical to the proper maintenance of the vehicle.
Daily cleaning of the hopper and chassis is crucial because it will minimize breakdowns and
maintenance expenses. Daily wiping down of all truck lights, warning lights and safety labels will make
your vehicle more visible so that surrounding pedestrians and vehicles will be safer around it.
The procedures described in this section are necessary for the vehicle to be well maintained and for
the operator to be safe while cleaning the vehicle.
Hopper cleaning procedure:
1.
Park the vehicle on level ground and apply the parking brake.
2.
Fully extend the arm and the packer.
3.
Lower the crusher panel (if installed) and clean all accumulated dirt. Then, raise the crusher
panel completely.
4.
Perform the lockout/tagout procedure (see
Locking Out and Taging Out the Vehicle
5.
Open the clean-out traps located on each side of the truck.
Summary of Contents for Automizer Versa Hand
