Table of Contents
L and Pride
Table of Contents
FDR3590 Rear Discharge Grooming Mowers 310-229M
12/10/07
©
Copyright 2007 All rights Reserved
Land Pride provides this publication “as is” without warranty of any kind, either expressed or implied. While every precaution has been taken in the preparation of this manual, Land
Pride assumes no responsibility for errors or omissions. Neither is any liability assumed for damages resulting from the use of the information contained herein. Land Pride reserves
the right to revise and improve its products as it sees fit. This publication describes the state of this product at the time of its publication, and may not reflect the product in the future.
Land Pride is a registered trademark.
All other brands and product names are trademarks or registered trademarks of their respective holders.
Printed in the United States of America.
Important Safety Information . . . . . . . . . . .1
Safety at All Times . . . . . . . . . . . . . . . . . . . . . . . . . 1
Look For The Safety Alert Symbol . . . . . . . . . . . . . 1
Safety Labels . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
Introduction . . . . . . . . . . . . . . . . . . . . . . . .7
Application . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Using This Manual . . . . . . . . . . . . . . . . . . . . . . . . . 7
Terminology . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Definitions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Owner Assistance . . . . . . . . . . . . . . . . . . . . . . . . . 7
Serial Number Plate . . . . . . . . . . . . . . . . . . . . . 7
Further Assistance . . . . . . . . . . . . . . . . . . . . . . 7
Section 1: Assembly and Set-up . . . . . . . .8
Tractor Requirements . . . . . . . . . . . . . . . . . . . . . . 8
Upper Hitch Arms . . . . . . . . . . . . . . . . . . . . . . . . . 8
Gauge Wheels . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Tractor Hook-Up . . . . . . . . . . . . . . . . . . . . . . . . . . 9
PTO Hookup . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Checking Driveline Minimum Length . . . . . . . . . 9
Checking Driveline Maximum Length . . . . . . . 10
Accessory Equipment . . . . . . . . . . . . . . . . . . . . . 11
Anti-Scalping Front Roller . . . . . . . . . . . . . . . . . . 11
Cutting Blades . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Low Lift Blades . . . . . . . . . . . . . . . . . . . . . . . . 11
Medium Lift Blades . . . . . . . . . . . . . . . . . . . . . 11
High Lift Blades . . . . . . . . . . . . . . . . . . . . . . . . 11
Mulching Blades . . . . . . . . . . . . . . . . . . . . . . . 11
Accessory Part Numbers . . . . . . . . . . . . . . . . . . . 11
Section 2: Operating Instructions . . . . . .12
Tractor Shut Down Procedure . . . . . . . . . . . . . . . 12
Operation Check . . . . . . . . . . . . . . . . . . . . . . . . . 12
Transporting . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
Mowing Instructions . . . . . . . . . . . . . . . . . . . . . . . 12
Un-hooking the Mower . . . . . . . . . . . . . . . . . . . . . 13
General Operating Instructions . . . . . . . . . . . . . . 14
Section 3: Adjustments . . . . . . . . . . . . . .15
Leveling the Mower . . . . . . . . . . . . . . . . . . . . . . . 15
Cutting Height Adjustment . . . . . . . . . . . . . . . . . . 15
3-Point Hitch Adjustments . . . . . . . . . . . . . . . . . . 16
Belt Tension . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
Section 4: Maintenance and Lubrication 17
Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17
Service Mowing Blades . . . . . . . . . . . . . . . . . . . . 17
Blade Inspection . . . . . . . . . . . . . . . . . . . . . . . 17
Blade Removal And Installation . . . . . . . . . . . . 17
Blade Sharpening or Replacement . . . . . . . . . 18
V-Belt Installation . . . . . . . . . . . . . . . . . . . . . . . . . 19
Storage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
Lubrication . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20
Driveline Shaft U-Joints . . . . . . . . . . . . . . . . . . 20
Inner Tube Bearings . . . . . . . . . . . . . . . . . . . . 20
Driveline Profiles . . . . . . . . . . . . . . . . . . . . . . . 20
Gearbox . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21
Wheel Support Bushings & Wheel Bearings . . 21
Bearing in Blade Spindle Hubs . . . . . . . . . . . . 21
Section 5: Specifications & Capacities . .22
Section 6: Features and Benefits . . . . . .23
Section 7: Troubleshooting . . . . . . . . . . .24
Section 8: Appendix . . . . . . . . . . . . . . . . .25
Torque Values Chart . . . . . . . . . . . . . . . . . . . . . . 25
Notes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26
Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27
