MAINTENANCE AND LUBRICATION
4-3
Table 4-1: Lubrication Specifications
Maintenance Procedures
Repair Parts
Repair parts are illustrated and listed in a separate parts
manual. Replacement of parts due to wear is determined
by examination and measurement in the Maintenance
Procedures of this section.
Tools and Equipment
Tools, equipment, and personnel normally found in a
facility capable of making truck repairs will be adequate
for maintenance of the semitrailer. No other special tools
or equipment should be necessary.
Torque Values
list torque values for standard
hardware and hydraulic fittings. They are intended as a
guide for average applications involving typical stresses
and mechanical surfaces. Values are based on the
physical limitations of clean, plated, and lubricated
hardware. In all cases, when an individual torque value is
specified, it takes priority over values given in this table.
Replace original fasteners with hardware of equal grade.
Cleaning
1.
Wash semitrailer to remove all accumulated dirt and
grime.
2.
Use any mineral spirits paint thinner (or its
equivalent) to remove grease and oil from all parts of
the trailer. Rinse degreasing solution off with cold
water.
3.
Inspect semitrailer for cause of any reported troubles.
WARNING
4.
Scrape, sand, prime, and repaint areas where finish
is missing or where there is evidence of corrosion.
LUBE
SEASON
BRAND AND PRODUCT
(WEIGHT AND/OR TYPE)
AMOCO
EXXON
PHILLIPS
TEXACO
1
ALL YEAR Rycon MV
HDX Plus 10W
Mangus Oil
A KV 5W-20
Rando HD-AZ
2
SUMMER
Permagear EP
SAE 140
Spartan 460
SAE 140
Phil Gear Lube 460
SAE 140
Meropa 460
SAE 140
WINTER
Permagear EP 220
SAE 90
Spartan 220
SAE 90
Phil Gear Lube 220
SAE 90
Meropa 220
SAE 90
3
ALL YEAR Lit-Multi-purpose
Grease
Rondex Multi-purpose
Grease
Phil Lube M.W. Grease MarFax All Purpose
4
ALL YEAR Industrial Oil 32
Estic 32
Condor 32 or Magnus
32
Regal Oil R & O 32
5
ALL YEAR Gear Lube SAE
80W-90
Gear Oil GX SAE
80W-90
Superior MP Gear Oil
SAE 80W-90
Multi-gear EP SAE
80W-90
6
ABOVE 0º
F
Ultimate Gold 10W-30,
10W-40
SuperFlow 10W-30,
10W-40
Tropartic 10W-30,
10W40
Havoline 10W-30,
10W-40
BELOW
32º
Ultimate Gold 5W-20,
5W-30
SuperFlow 5W-20,
5W-30
Tropartic 5W-20, 5W-30 Havoline 5W-20, 5W-30
Paint thinner and other solvents are flammable
and toxic to eyes, skin, and respiratory tract.
Avoid skin and eye contact. Good general
ventilation is normally adequate. Keep away from
open flames or other combustible items.
Summary of Contents for 425B Series
