1-6
F-459-R1
INTRO, SAFETY, INSPECTION AND DASH OPERATIONS
• Move truck to a level area designated for repair.
• Keep forks empty and low to the ground.
• Turn the key off and remove it from the console.
• Unhook the battery.
• Attach Lock Out/Tag Out device to the truck.
• Use a jack or hoist with a 8000 lb. minimum lift.
• Set the lift on designated hardwood blocks. See
Figure above for block(s) placement. Four blocks
are required on all four corners of the truck to
provide a safe, stable repair position.
• Keep the height of the lifted truck to a minimum.
Cleaning the truck
Landoll Corporation recommends that their fork trucks
NOT be cleaned with a power washer. Electrical boards,
circuitry and wiring can be damaged by high pressure
water and soap. Moisture and soap left on components
can rust, corrode or leave a residue that can damage
everything that it comes in contact with. The preferred
method of removing dust is compressed air. For localized
cleaning, use a non-flammable solvent parts washer and
compressed air after the part or area is cleaned.
Maintenance Introduction
Preventative maintenance is an important part of all
industrial equipment.
A well planned preventative maintenance program is
essential to keeping the working environment safe for the
operator and the longevity of the affected equipment.
Regular and planned maintenance is the responsibility of
both the daily operator and the forklift technician.
Inspection Sheets
The following pages are OSHA (Occupational Safety and
Health Administration) required check sheets. These
sheets should be copied and the copies used for
maintenance checks on your SLT30/35 AC lift. The
pre-shift inspection on your SLT30/35 AC lift is an OSHA
requirement. It is the operator’s duty to inspect the lift
before each shift and report all problems to the person in
charge of forklift maintenance. Have a qualified mechanic
correct all noted problems.
Daily pre-shift inspection is an OSHA requirement.
These inspections must be documented.
https://www.forkliftpdfmanuals.com/
