11
WARNING
MAINTENANCE & CLEANING
Cleaning
• Always start with a cold griddle.
• The stainless exterior can easily be cleaned using a good non-abrasive cleaner.
• Always follow the cleaner manufacturer’s instructions when using any cleaner.
• Always apply these cleaners when the griddle is cold and rub in the direction of the metal’s grain.
Griddle Surface Care (non-chromium surfaces)
It takes very little time and effort to keep the griddle attractive and performing at top efficiency. If grease
is permitted to accumulate, it will form a gummy cake and then carbonize into a hard substance which is
extremely difficult to remove. To prevent this condition, the following suggestions for cleanliness should be
followed:
•
After each use, scrape the griddle with a scraper or flexible spatula to remove excess grease and
food. A waste drawer is provided for the scrapings. If there is an accumulation of burned on grease
and food, the griddle should be thoroughly scoured and re-seasoned. Use pumice or griddle stone
while the griddle is warm.
Do not use steel wool because of the danger of steel slivers getting into the food.
Griddle Care (Chromium Surfaces)
It takes very little time and effort to keep this Industrial Chromium griddle surface sparkling clean and
performing at top efficiency. DO NOT allow grease to accumulate as it will carbonize and become difficult to
remove. To prevent this condition the following cleaning suggestions should be followed:
1.
Remove excess grease and food regularly with a 4” (100mm) wide Razor Sharp type scraper and
wipe surface with a damp cloth if desired.
2.
Following the scraping, for end of the day cleaning, a damp cloth and a non-silicated, nonabrasive,
non-chlorinated cleaner such as Bon-Ami may be used to wipe surface clean, followed by wiping with
a clean wet cloth.
3.
Follow steps 2 and 3 from Griddle Care (Non-Chromium Surfaces) above.
CAUTION
1.
Never
use pumice, griddle stones, or abrasives on a chromium surface.
2.
Never
strike a chromium griddle surface with a sharp instrument or spatula edge.
3.
Never
use steel wool.
4.
Never
use commercial liquid grill cleaner on the griddle surface.
5.
Abusing
surface voids the warranty.
KEEP WATER AND SOLUTIONS OUT OF CONTROLS. NEVER SPRAY
OR HOSE CONTROL CONSOLE.
MOST CLEANERS ARE HARMFUL TO THE SKIN, EYES, MUCOUS
MEMBRANES AND CLOTHING. PRECAUTIONS SHOULD BE TAKEN
TO WEAR RUBBER GLOVES, GOGGLES OR FACE SHIELD AND
PROTECTIVE CLOTHING. CAREFULLY READ THE WARNING AND
FOLLOW THE DIRECTIONS ON THE LABEL OF THE CLEANER TO BE
USED.
NOTICE: Never leave a chlorine sanitizer in contact with stainless steel surfaces
longer than 10 minutes. Longer contact can cause corrosion.
CAUTION
Summary of Contents for EnviroZone 124ZD
Page 15: ...15...
