41
8. TROUBLESHOOTING
PROBLEM
PROBABLE CAUSE
REMEDY SUGGESTED
Falls to split logs
Log is Improperly positioned
Refer to" Log Splitter
Operation" section for
perfect log loading.
The sizes or hardness of the log.
exceeds the capacity of the
machine
Reduce the log sizes before
splitting it on the log splitter
Wedge cutting edge is blunt
Refer to" Sharpening the
Wedge” section to sharpen
the cutting edge.
Oil leaks
Locate leak(s) and contact
the dealer
Unauthorized adjustment was
made on Max. Pressure Limiting
Screw. Lower max pressure
rating was set.
Contact the dealer.
The log pusher moves
jerkily, taking unfamiliar
noise or vibrating a lot
Lack of hydraulic oil and
excessive air in the hydraulic
system.
Check oil level for possible
oil refilling. Contact the
dealer.
Oil leaks around cylinder
ram or from other points.
Air sealed in hydraulic system
while operating.
Loosen Bleed Screw by
3~4 rotations before
operating the log splitter
Bleed Screw is not tightened
before moving the log splitter.
Tighten the Bleed Screw up
before moving the log
splitter.
Oil Drain Bolt with Dipstick is not
tight.
Tighten the Oil Drain Bolt
with Dipstick.
Hydraulic Control Valve Assembly
and / or seal(s) worn
Contact the dealer
Motor does not start
No current in the socket
Check mains fuse
Electrical extension line defective Unplug, Check and replace.
Switch or capacitor defective.
Have checked by
Electrician
Log Splitter does not work
while motor running
Valve is not opened owing to the
connection parts loosening
Check and tighten the
parts.
Control Levers or Connection
parts bent.
Repair the bent parts
Lower hydraulic oil level
Check and refill hydraulic
oil.
9. STORAGE
-
Keep the product, the instructions manual and all accessories in the original packaging.
-
It is recommended to store the tool in a dry location out of children’s reach.
-
Cover the splitter properly if you store it in a shelter or in poorly protected room.
-
Protect the motor and especially the switch against water and moisture.
-
Do not store anything above or on the splitter
Summary of Contents for LE581504H
