Lennox XC21, Installation Instructions Manual

Page 49

XC21 SERIES

HOMEOWNER

Cleaning of the outdoor unit’s coil should be performed by
a trained service technician. Contact your dealer and set
up a schedule (preferably twice a year, but at least once a
year) to inspect and service your outdoor unit. The
following maintenance may be performed by the
homeowner.

CAUTION

Electrostatic discharge can affect electronic
components. Take precautions during unit installation
and service to protect the unit’s electronic controls.
Precautions will help to avoid control exposure to
electrostatic discharge by putting the unit, the control
and the technician at the same electrostatic potential.
Neutralize electrostatic charge by touching hand and all
tools on an unpainted unit surface before performing any
service procedure.

IMPORTANT

Sprinklers and soaker hoses should not be installed
where they could cause prolonged exposure to the
outdoor unit by treated water. Prolonged exposure of the
unit to treated water (i.e., sprinkler systems, soakers,
waste water, etc.) will corrode the surface of steel and
aluminum parts and diminish performance and longevity
of the unit.

Outdoor Coil

The outdoor unit must be properly maintained to ensure its
proper operation.

S

Please contact your dealer to schedule proper
inspection and maintenance for your equipment.

S

Make sure no obstructions restrict airflow to the
outdoor unit.

S

Grass clippings, leaves, or shrubs crowding the unit
can cause the unit to work harder and use more
energy.

S

Keep shrubbery trimmed away from the unit and
periodically check for debris which collects around the
unit.

Routine Maintenance

In order to ensure peak performance, your system must be
properly maintained. Clogged filters and blocked airflow
prevent your unit from operating at its most efficient level.

1.

Air Filter

 Ask your Lennox dealer to show you

where your indoor unit’s filter is located. It will be either

at the indoor unit (installed internal or external to the
cabinet) or behind a return air grille in the wall or
ceiling. Check the filter monthly and clean or replace
it as needed.

2.

Disposable Filter 

 Disposable filters should be

replaced with a filter of the same type and size.

NOTE 

 If you are unsure about the filter required for your

system, call your Lennox dealer for assistance.

3.

Reusable Filter

 Many indoor units are equipped

with reusable foam filters. Clean foam filters with a
mild soap and water solution; rinse thoroughly; allow
filter to dry completely before returning it to the unit or
grille.

NOTE 

 The filter and all access panels must be in place

any time the unit is in operation.

4.

Electronic Air Cleaner

 Some systems are

equipped with an electronic air cleaner, designed to
remove airborne particles from the air passing through
the cleaner. If your system is so equipped, ask your
dealer for maintenance instructions.

5.

Indoor Unit 

 The indoor unit’s evaporator coil is

equipped with a drain pan to collect condensate
formed as your system removes humidity from the
inside air. Have your dealer show you the location of
the drain line and how to check for obstructions. (This
would also apply to an auxiliary drain, if installed.)

Thermostat Operation

See the ComfortSense

®

 7000 or icomfort Touch

t

thermostat homeowner manual for instructions on how to
operate your thermostat.

Preservice Check

If your system fails to operate, check the following before
calling for service:

S

Verify room thermostat settings are correct.

S

Verify that all electrical disconnect switches are ON.

S

Check for any blown fuses or tripped circuit breakers.

S

Verify unit access panels are in place.

S

Verify air filter is clean.

S

If service is needed, locate and write down the unit
model number and have it handy before calling.

Accessories

For update−to−date information, see any of the following
publications:

S

Lennox XC21 Engineering Handbook

S

Lennox Product Catalog

S

Lennox Price Book