54
VII. Parking
1. Parking daily
①
Park your truck to desired place and block
the wheels.
②
Make sure the shift level is in the neutral
position.
③
Apply the parking brake.
④
Shut the engine down and move the lift and
tilt levers several times so that the inner
pressure in the hydraulic tubes will be
released.
⑤
Remove the key and take it with you.
Warning
You should tell the manager if you find any
problems with the truck, and have them
repaired immediately.
Do the following things
：
①
Clean oil and grease stains with a cloth and
water on the truck body.
②
Check the whole truck, especially the tires.
③
Fill the fuel tank with the proper fuel.
④
Check for leaks of hydraulic oil, engine oil,
LPG and coolant.
⑤
Apply lubricate grease
⑥
Check whether the junction plane between
the nuts of wheel boss and the piston of hydro
cylinder are loose, and whether the surface of
piston has been pulled.
⑦
Check mast rollers operate smoothly.
⑧
Lift the lifting cylinder to the top and fill it with
oil.
⑨
In cold weather, it is not necessary to drain
the antifreeze, but the water should be
completely drained from the radiator.
尽。
2. Park the truck for a long time
When parking the truck for a long period,
place blocks under the truck body and
counterweight to reduce the load on two rear
wheels.
Warning
a.
The block must be single and hard
enough to support the truck.
b.
Don‟t use blocks higher than
300 mm
（
11.81 inch
）
.
c.
Lift the truck to place it on the blocks.
d.
Use the same size blocks under the
left and right sides of the truck.
e.
While the truck is supported by the
blocks, swing the truck forward, backward,
left and right, check its safety.
Perform the following maintenance for long
term truck storage:
①
Remove the battery and recharge it once a
month, keep it in a shady place.
②
Brush antirust oil on those parts that are
exposed to the air, such as piston rods and
axles.
③
Put a cloth on vent-plug and air-cleaner.
④
Start the engine once a week. If the water
has already been removed, add water in the
radiator. Then run the engine at low speed and
operate the mast several times.
⑤
In summer, it is not recommended to park
the fork on asphalt road.
3. Running after storing for a long
time
①
Remove the antirust oil from the exposed
parts.
