Date:
5/25/07
MSDS No.:
CAN-M306
Trade Name:
Shield Arc HYP+
Sizes: All
Supersedes: 5/24/04
M A T E R I A L S A F E T Y D A T A S H E E T
For Welding Consumables and Related Products
Conforms to Workplace Hazardous Materials Information System (WHMIS) Rev. November, 1988
Section I & II - Preparation and Product Information
Product Type:
Covered Electrode
Representative Classifications:
AWS E7010-P1
CSA E4910-P1
The Lincoln Electric Company of Canada LP
179 Wicksteed Avenue
Toronto, Ontario M4G 2B9 CANADA
Phone: (416) 421-2600
Prepared by The Lincoln Electric Company, Cleveland, Ohio, USA
(216) 481-8100, on the date shown above.
Section III - Hazardous Ingredients (1)
I M P O R T A N T !
This section covers the materials from which this product is manufactured. The fumes and gases produced during welding with the normal use of this
product are covered by Section VII; see it for industrial hygiene information.
CAS Number shown is representative for the ingredients listed. All ingredients listed may not be present in all sizes.
(1)
The term “hazardous” in “Hazardous Ingredients” should be interpreted as a term required and defined in the Hazardous Products Act and does
not necessarily imply the existence of any hazard.
Ingredients:
CAS No. Wt. %
TLV
mg/m
3
LD
50
(Route/Species)
LC
50
mg/m
3
(Route/Species)
Cellulose and other carbohydrates
65996-61-4
1-5
10*
Not Available
Not Available
Silicates and other binders
1344-09-8
1-5
10*
1153 mg/kg
(oral/rat)
Not Available
Iron 7439-89-6
1-5
10*
Not Available
Not Available
Titanium dioxides (as Ti)
13463-67-7
1-5
10
Not Available
Not Available
Mineral silicates
1332-58-7
1-5
5**
590 g/kg LDLo
(oral/rat) reproductive
Not Available
Manganese and/or manganese alloys and compounds (as Mn)
7439-96-5
1-5
0.2
9 g/kg
(oral/rat)
2.3 LCLo
(inhalation/human)
Iron oxides (as Fe)
65996-74-9
0.1-1
5
Not Available
Not Available
Magnesite 1309-48-4
0.1-1
10
Not Available
Not Available
Alkali carbonates
584-08-7
0.1-1
10*
1870 mg/kg
(oral/rat)
Not Available
Molybdenum alloys (as Mo)
7439-98-7
0.1-1
10
114 mg/kg LDLo
(intraperitoneal/rat)
Not Available
Carbon steel core wire
7439-89-6
60-100
10*
Not Available
Not Available
Notes:
(*) Not listed. Nuisance value maximum is 10 milligrams per cubic
meter. TLV value for iron oxide is 5 milligrams per cubic meter.
(**)
As respirable dust.
(LDLo, LCLo) Lowest published toxic concentration.
Section IV - Physical Data
Physical data such as odor, vapor pressure, density, evaporation rate and freezing or boiling points are not listed as they are not applicable to
this product and its use.
Section V - Hazard Data
Non Flammable; Welding arc and sparks can ignite combustibles and flammable products. See CSA W117.2 Section 9.7 as referenced in
Section VIII. Product is inert, no special handling or spill procedures required.
Rev 3/07
(CONTINUED ON SIDE TWO)
