MAINTENANCE/SERVICE
Form 169469/169470/169471
136
Revision C
7.7.6.2 Return Air Cleaner
The return air filter is located behind the
operator’s seat on the cab wall and should be
serviced every 100 hours as follows:
DANGER
Stop engine and remove key from ignition
before leaving operator's seat for any
reason. A child or even a pet could engage
an idling machine.
a. Unscrew the two knobs (D) attaching cover and
filter to cab wall, and pull off the cover and filter
assembly.
b. Separate the filter (E) from the cover (F).
c. Clean the electrostatic filter as follows:
1. Mix a solution of warm water and detergent
in a suitable container so that the filter can
soak for a few minutes.
2. Agitate to flush out the dirt.
3. Rinse with clean water and dry with
compressed air.
4. Inspect filter for damage, separation, and
holes. Replace if damaged.
d. Assemble the cleaner (E) and cover (F) and
position on cab wall over opening.
e. Secure to cab wall with knobs (D).
7.7.6.3 A/C Condenser
The air conditioning condenser should be
cleaned daily with compressed air and more
frequent cleaning may be necessary in severe
conditions. Cleaning the condenser can be
done at the same time as the radiator, oil cooler,
and charge air cooler. Refer to Section 7.9
COOLING BOX.
7.7.6.4 A/C Evaporator
The air conditioning evaporator should be
checked annually for cleanliness. If the air
conditioning system produces insufficient
cooling, a possible cause is clogged evaporator
fins. Fins will clog up from the side opposite the
blowers.
The evaporator is located inside the heating air
conditioning unit under the cab. To clean the
evaporator, proceed as follows:
DANGER
Stop engine and remove key from ignition
before leaving operator's seat for any
reason. A child or even a pet could engage
an idling machine
a. Loosen the clamps (G) on the two drain hoses
and pull the hoses off the air conditioning drain
tubes.
(continued next page)
D
G
F
E
Summary of Contents for M205 2010
Page 1: ...M205 Self Propelled Windrower OPERATOR S MANUAL Revision C Part 169469 25...
Page 51: ...OPERATOR S STATION Form 169469 169470 169471 49 Revision C continued next page...
Page 95: ...HEADER OPERATION D SERIES Form 169469 169470 169471 93 Revision C continued next page...
Page 181: ...MAINTENANCE SERVICE Form 169469 169470 169471 179 Revision C 7 10 13 3 Fuse Box Decal...
