DESCRIPTION AND OPERATION
Page 49
47
Figure 47 — Rocker Shaft
Oil is supplied to the rocker shaft through an oil
supply passage in the front rocker shaft mounting
bracket. This mounting bracket is “press-fit” on
the rocker shaft, whereas the middle and rear
mounting brackets are a new “slip-fit” design. An
oil supply screen is located in the counterbore of
the oil passage at the bottom of the rocker shaft
mounting bracket.
48
Figure 48 — Front Rocker Shaft Mounting Bracket
This screen is a relatively fine (100 x 100 mesh)
stainless steel screen with a nominal rating of
40 microns. The purpose of this screen is to
protect the engine brake hydraulic actuator
against any initial debris that may be circulating
with the oil at initial start-up following an engine
rebuild or repair. Servicing the screen at any
regular service interval is not required. The
screen should be cleaned after any type of
engine failure that has contaminated the
lubrication system, if rocker shafts have been
removed for any reason or after a major engine
overhaul. Additionally, the screen should be
inspected and cleaned if troubleshooting
procedures for engine brake operation indicate a
drop in oil pressure at the rocker shafts.
앫
Exhaust Valve Yoke
— The inboard side of
the exhaust yokes contains a hole for the
exhaust valve actuating pin. The actuating
pin rests on a cap that is installed over the
tip of the valve stem on the inboard exhaust
valve.
1. Engine Brake Solenoid Port
2. Control Oil Gallery
3. Constant Supply Oil Gallery
1. Front Mounting Bracket
2. Oil Supply Port
3. Oil Supply Screen
5-111.bk Page 49 Monday, July 10, 2006 2:26 PM
Summary of Contents for ASET AC
