1/12
15
Clean Blended Ice Machine (BIM-8)
(continued)
©McDonald’s Corporation · Planned Maintenance Manual · October 2011
Page 4 of 5
Bl
e
Blended Ice Machine Models
M
S-8-1H, MS
-8-1LH
, MS
-8-E
H,
MS
-8-E
LH, MS
-8-
BH, MS
-8-B
LH
, MS
-8-CH, MS
-8-CLH,
M
S000A
03
, MS
000A
04
Weekly
BE 23 W1
31
With the blender pitchers at
the 3-compartment sink:
Place one KAY Beverage
Equipment Cleaner packet
into the first pitcher and fill
with
hot
water from the back
sink. Allow the product to
soak in the pitcher for 5
minutes. Use a no-scratch pad
to remove any film build-up.
Pour the solution into the
second pitcher and soak for 5
minutes. Once this is done,
discard solution and rinse and
sanitize both pitchers in the 3-
compartment sink. Allow to
air dry.
KAY Beverage Equipment
Cleaner
32
Sanitize ice chute
Use a spray bottle with
Sanitizer solution and a
sanitized towel to sanitize:
x
Above and around the
ice chute
x
Inside the ice chute
KAY 5 Sanitizer
33
Clean pitcher pad and drain
area.
x
Use coffee pot of hot
water from the back
sink to rinse drain
area and drain.
x
Spray the drain area
with Sanitizer
solution and wipe
with a clean sanitize
towel.
x
Clean top and sides
of the pad.
KAY 5 Sanitizer
34
Re-install all components.
Blend pitchers, scale overflow
tray, ice hopper lid, syrup
rails, drip pan and splash
guard.
35
Clean with APSC the interior of
the blended ice machine with a
clean, sanitized towel
dampened with KAY 5
Sanitizer solution:
x
Clean inside the
machine.
x
Pull out the whipped
cream holder and clean
the holder and sides
inside the machine that
hold the holder
x
Clean all door gaskets
KAY 5 Sanitizer
36
Clean with APSC the exterior
of the blended ice machine
with a clean, sanitized towel
dampened with KAY 5
Sanitizer solution:
x
Clean lid holders, cup
holder tubes, cabinet,
front of door, top of
work surface, touch
screen, outside of ice
hopper
KAY 5 Sanitizer
37
Slowly pour two full pitchers of
hot water from the back sink
into the rinse area.
38
On top of the BIO-SHIELD®
dispenser open the pressure
relief knob by turning the knob
counter clockwise.
39
Remove the cap from the BIO-
SHIELD® dispenser.
continued
X
Summary of Contents for Multiplex Ms-8
Page 59: ...1 12 59 Blender Scale Schematic Shaver Schematic ...
Page 62: ...62 1 12 Notes ...
Page 63: ...1 12 63 Notes ...
