6
1. Make certain the AC charging cord is
unplugged from the wall outlet.
2. Remove the Front Cover of the cart.
3. Remove the knob that secures the Battery
Hold Down Plate. Remove the Battery Hold
Down Plate.
4. Pull the Battery out of the enclosure to
expose the positive lead. Disconnect the
positive lead from the Battery (Red).
5. Pull the Battery out of the enclosure to
expose the negative lead on the battery.
Disconnect negative lead.
6. Do NOT short battery terminals together.
7. Re-Installation should be done in reverse
order. Start at step 6 and work back to
step 1. Take care to place the positive lead
protective boot back onto the positive
terminal of the battery before completing
installation.
BATTERY REMOVAL AND
INSTALLATION STEPS
NOTICE
Batteries used in the Evolution 4 are specific to
this model to provide the optimum life cycle and
preserve the integrity of the proprietary Power
Management System. It is recommended that only
this battery be installed into this cart.
It is important that battery specifications are
observed. This cart is equipped with a high current
charger that could damage batteries that do not
meet the specification indicated below. Use only
batteries specified for the Evolution 4. Contact
Mart Cart Service for replacement batteries.
Voltage Per Unit
12v
Capacity 39.0Ah @ 20hr-rate to 1.75v per cell @ 25°C (77°F)
Maximum Discharge Current
400A (5 Sec)
Float Charging Voltage
13.5 to 13.8 VDC/unit Average at 25°C (77°F)
Maximum Charging Current Limit
11.7A
Terminal
B5-L Terminal to accept M6 nut and bolt
Case
Size U1
DEPLETED BATTERY
The Power Management System will prompt the LCD
screen to display the battery icon when the cart
battery is too low to operate. When this happens,
charge the battery.
NOTE:
The cart should be charged every night, all
night, and at every opportunity.
STORE PERSONNEL OVERRIDE
The Evolution 4 has reserve power should the battery
be run down while in the store. To operate the cart
while returning to the charging station continuously
hold down the Horn Button while engaging the
throttle. The horn will sound for approximately one
second before going silent. Keep horn and throttle
engaged to operate.
WARNING
WARNING
Failure to follow instructions many result in
death or serious injury.
