Typical processing capacity (cartridge life) @ 72
o
F intake temperature for
Grade “E” breathing air SCUBA or SCBA @ 5000 psi.
Compressor model Max
-
Air 55 = 35,000 cubic feet (
or prox 106 hours of running time
)
Compressor model Max
-
Air 90 = 35,000 cubic feet (
or prox 65 hours of running time
)
MAKE SURE WHENEVER CHECKING FILTRATION THAT THE
SYSTEM IS SHUT OFF AND COMPLETELY DRAINED OF AIR PRESSURE
NOTE:
1.
The cartridge life is based on 72
o
F intake temperature, draining the condensate
every 15 minutes or more often if in hot and humid climate
2.
The 35,000 cubic feet must be de
-
rated by 2% for every 1
o
F above 72
o
F.
The reverse applies to temperatures below 72
o
F.
i.e.
@ 82
o
F decrease capacity by 20%
@ 92
o
F decrease capacity by 40%
@ 102
o
F decrease capacity by 60%
DO NOT
use where temp. could exceed 120F.
CARTRIDGE COMPONENT IDENTIFICATION:
A.
Sealed foil envelope (not shown) –makes sure it is not torn or punctured.
Do not open until ready to install.
For extended storage re
-
wrap in two
or three heavy duty zip lock bags. Store in a cool, dry, dark place.
B.
Lifting handle for ease of installation, fold back flat prior to screw down housing cap.
C.
Read and remove tape c
D.
Remove snap
-
out plastic plug under tape.
E.
Remove plastic plug, make sure internal O’ring is present and lubricated
(use silicone grease only)
F.
LifeBand
tm
changes color from blue to beige along entire length.
Replace
ALL
cartridges in system at this time. It is advisable to pull out
cartridge every 5 hours to inspect LifeBand
tm
and for any sign of moisture.
G.
Warning label read and understand this and any labels on the filter.
H.
Molecular sieve (beige beads) removes humidity
I.
Hopcalite catalyst converts trace amounts of carbon monoxide to carbon dioxide
J.
Activated charcoal removes bad odors and taste of lubricant
K.
Internal O’ring is located inside black plastic sleeve and can only be seen
after removing “E”. Make sure the O’ring is in place and in good condition.
•
Maximum cartridge life, once installed, is six months regardless if it has not
reached the full processing capacity.
•
Maximum shelf life in unopened package is two (2) years
YOU MUST READ AND UNDERSTAND THIS INFORMATION
PRIOR TO FILLING BREATHING AIR CYLINDER!!
BREATHING AIR PURIFICATION FILTER CARTRIDGE (DISPOSABLE)
Part Number LF
-
65247
Fits all Max
-
Air compressors with upgraded purification PU
-
35000 for breathing air
Page 14 of 22
