McDonald's 9210859, Manual

HEBT-3V BUN TOASTER

1

P/N 1011377 Rev. G   07/17 

McDonald’s

BUN TOASTER  

HEBT-3V  

9210859, 9210860, 9210861 & 9210863

Place this manual in the Toaster section  

of your 

Equipment Manual. 

Manufactured exclusively for 

McDONALD’S® 

BY

ANTUNES 

180 KEHOE BLVD. 

CAROL STREAM, ILLINOIS 60188, U.S.A. 

PHONE: +1-630-784-1000 

TOLL FREE: +1-877-392-7854 

FAX: +1-630-784-1650 

www.antunes.com

TABLE OF CONTENTS

This manual is for the exclusive use of licensees and employees of McDonald’s Systems, Inc..  

© McDonald’s Corporation  All Rights Reserved

Owner Information .....................................................2

General ......................................................................2

Service/Technical Assistance ....................................2

Warranty Information .................................................2

Specifications .............................................................3

Electrical Specifications & Plug Configuration ..........3

Dimensions ................................................................3

Important Safety Information ....................................4

Installation ...................................................................5

Unpacking ..................................................................5

Location .....................................................................5

Operation .....................................................................6

Operating Instructions ...............................................6

User Mode .................................................................6

Manager Mode ..........................................................6

Safety Features .........................................................7

Maintenance ................................................................8

Daily Cleaning ...........................................................8

Quarterly ..................................................................11

Clean Cooling Fans and Electrical Housings 

(Annually) ................................................................13

Troubleshooting .......................................................14

Replacement Parts ...................................................17

Wiring Diagram .........................................................24

Notes..........................................................................25

Scan with mobile device or enter URL

for product and service information.

A.J. Antunes & Co.

HEBT-3V

http://tiny.cc/ajaHEBT3V

LIMITED WARRANTY

A.J. Antunes & Co. provides the following limited warranty to the original purchaser of all McDonald’s Equipment. 

All components are warranted against defects in the material and workmanship for a period of two (2) years. If any part becomes inoperable during the period of this 

warranty, A.J. Antunes & Co. will pay labor costs to an Authorized Service Agent to replace the part plus travel expenses.

A.J. Antunes & Co. reserves the right to make changes in design or add improvements on any products. The right is always reserved to modify Equipment because of 

factors beyond our control and government regulation. Changes to Equipment do not constitute a warranty charge. 

This warranty is exclusive and is in lieu of all other warranties, expressed or implied, including any implied warranty of merchantability or fitness for a particular pur-

pose, each of which is expressly disclaimed. The remedies described above are exclusive, and in no event shall A.J. Antunes & Co. or any of its Divisions be liable for 

special consequential or incidental damages for the breach or delay in the performance of this warranty.

WARRANTY EXCLUSIONS

•  The cost of installation.

•  Equipment that has been damaged due to shipment. Purchaser should make 

damage claim directly upon carrier.

•  Alteration, misuse, abuse.

•  Improper storage or handling.

•  Improper maintenance.

•  Failure to follow proper installation instructions, including electrical connec-

tion.

•  Improper or unauthorized repairs.

•  Scheduled Maintenance procedures as outlined in your MRC Card.

•  Consumables such as Grill Covers (Release Sheets), gaskets, Conveyor Belt 

Wraps, O-rings, removal of links, and light bulbs.

•  Freight, foreign, excise, municipal, or other sales or use taxes.

•  Consequential damages such as loss of profit, loss of time, the cost of repair-

ing or replacing other property which is damaged, or any other incidental 

damage of any kind.