490 Pilothouse • Owner’s Manual
Chapter 11: Electrical Systems
75
Generator
•
When your yacht is not connected to shore power, the generator can supply 110-volt/60-hertz power.
•
Before using the generator, read the generator operation manual for pre-start checks and break-in procedures.
•
Refer to the generator manual for starting/stopping instructions.
Important generator notes:
•
Polarity has been established in the installation of the generator. Therefore the polarity lights will not function in
this mode.
•
Fuel to run the generator is supplied from the starboard fuel tank.
•
Periodically replace the filter on the generator to make sure it remains clean and free of debris.
•
Diesel generators also have a fuel filter/water separator. Service instructions are provided on the fuel
filter/water separator.
•
The coolant mixture installed at the factory consists of equal parts of water and antifreeze (Ethylene Glycol).
•
Check the generator’s seawater strainer for leaks and/or debris before each use.
CARBON MONOXIDE POISONING HAZARD!
•
Generators are a source of dangerous carbon monoxide gas (CO). Check the
generator exhaust system for leaks BEFORE each use.
•
Read the Carbon Monoxide (CO) section of Chapter 1 in this Owner’s
Manual.
DANGER !
!
FIRE and EXPLOSION HAZARD!
Fuel vapors can explode! BEFORE starting the generator:
1. Check the bilge areas for fuel vapors or leaking fuel. If you see leaking fuel or smell
fuel vapors:
a. Do NOT start the generator or the engines, do NOT turn On any electrical devices, and
put out ALL cigarettes, cigars, and other sources of flame or ignition.
b. Get everyone off your yacht.
c. Get trained help to find and fix the problem.
2. Run the bilge blowers for at least four minutes BEFORE generator or engine starting, elec-
trical system work, or turning on electrical devices.
•
If you smell fuel vapors and the generator is already running:
a. Shut Off the generator and turn Off ALL electrical devices.
b. Put out ALL cigarettes, cigars, and other sources of flame or ignition.
c. Get trained help to find and fix the problem.
WARNI N G!
!
SYSTEM DAMAGE HAZARD!
•
ALWAYS make sure the generator’s seawater intake seacock is Open BEFORE starting, and
during running of the generator.
•
NEVER run the generator starter for more than 30 seconds. If the generator does not start,
wait at least 30 seconds BEFORE trying again.
•
After the generator starts, let the generator stabilize BEFORE turning On the component
breakers on the 110-volt AC master panel.
CAUTI ON
!
Summary of Contents for 490 Pilothouse
