MEV™ Daytona™ OWNERS MANUAL
21
Charger:
On-‐board Charger
The charger is located beneath the front body, mounted on the rear outer wall of the front trunk
section. It begins the charge cycle after connecting the power plug to the charging receptacle
inside the ‘fuel’ cap on the driver’s side of the cart. At the same time the
LED indicator located on the driver’s side of the dash will flash to show the charger is charging
the battery pack, when fully charged the LED will stop blinking and remain lit until the charger is
disconnected.
Troubleshooting Instructions
If a fault occurs, count the number of red flashes on LED indicator, located on the side of the
charger, between pauses and refer to the table below and instructions:
Red Flashes
Cause
Solution
*
Battery high voltage.
Check battery size and condition and
reset charger (interrupt AC power for
15 seconds).
**
Battery low voltage.
Check battery size and condition and
reset charger (interrupt AC power for
15 seconds).
***
Charge timeout caused by battery
pack not reaching required voltage.
Charger output was reduced to
high temperatures.
Check connections:
Operate charger at a lower ambient
temperature.
****
Check battery: battery could not be
trickle charged up to minimum
voltage.
Check for shorted or damaged cells.
*****
Over-‐temperature: charger shut
down due to high internal
temperature.
Ensure sufficient cooling air flow and
reset charger (interrupt AC power for
15 seconds).
******
Charger internal fault.
Reset charger (interrupt AC power for
15 seconds). Return to qualified service
depot if fault persists.
•
Please see additional instructions to the rear of this Owner’s Manual.
