14 |
P a g e
M o d e l V B 2 3 5
TRACTOR TOWING SIZE REQUIREMENTS
The spreader does not have brakes, towing the spreader must be done safely. The ASAE (American Society of
Agricultural Engineers) specifies that the towing vehicle should weigh at least 2/3 as much as the loaded
implement to be reasonably safe towing at speeds up to 20 mph. This (20 mph) is also the maximum
recommended towing speed for the spreader.
The loaded weight of your spreader will naturally vary with the moisture of the manure and you must consider that
for your conditions. The loaded weight as specified by the spreader manufacturer is as follows:
Use the following charts for calculating spreader gross weight and minimum tractor weight:
HYDRAULIC SYSTEM
There are two hydraulic circuits on the spreader:
1. One circuit powers the hydraulic end gate.
2. The second circuit powers the hydraulic apron drive. A check valve is installed in this circuit to prevent
operating the apron in reverse. Also, the hydraulic motor has a built-in relief valve that is preset.
Therefore, the tractor requires two sets of remote ports with a minimum recommended flow of 15 GPM.
The hydraulic system is rated for 3000 PSI. Tractor relief settings should not exceed 2500 PSI!
The spreader ships from the factory setup for closed center systems.
LOAD TYPE
VB235 CAPACITY
Struck Level
235 ft
3
Heaped
390 ft
3
Calculations
Load Weight
Capacity (ft
3
) x Material Weight (lbs. / ft
3
) = Load Weight
Spreader Gross Weight
Empty Weight (9200 lbs) + Load Weight = Gross Weight
Minimum Tractor Weight
Spreader Gross Weight x (2/3) = Min Tractor Weight
ESTIMATED WEIGHTS PER CUBIC FOOT
Material
LBS / FT
3
Lime Sludge
110-115 LBS.
Dry Feedlot Manure
63-65 LBS.
Chicken Litter
63-65 LBS.
Cake Sludge
62-65 LBS.
Semi-Solid Manure
58-60 LBS.
Pen Packed Manure
30-35 LBS.
Liquid Manure
63-65 LBS.
NOTICE!
HEAPED LOADS HAVE SIGNIFICANTLY
HIGHER CAPACITIES RESULTING IN
INCREASED WEIGHT AND HIGHER CENTER
OF GRAVITY, REQUIRING EXTRA
PRECAUTION DURING OPERATION.
EXAMPLE
A heaped load of pen packed manure:
Load Weight
= 390 x 35 = 13,650 LBS
Gross Weight
= 9,200 + 13,650 = 22,850 LBS
Tractor Weight
= 22,850 x (2/3) = 15,233 LBS
Summary of Contents for VB235
