INSTALLATION AND OPERATION MANUAL, GAS FIRED STEAMER, MODELS GCX-2, GCX-10
PART NUMBER 10056R3
17
2009-03-24
5.0 OPERATION INSTRUCTIONS
COOKER SECTION
CAUTION: Live steam and accumulated hot water in the
compartment may be released when the door is opened.
Start-up procedures for your cooker must be completed once daily prior to operation (see
instruction plate or previous section in this manual for boiler start up procedures).
With ready pilot light on, preheat cooker compartment for one minute when the cooker is to be
first used for the day or whenever the compartment is cold.
1.
Close compartment doors and set timer to “1 minute”.
2.
When buzzer sounds, set timer to the “OFF” position.
3.
Cooker is now ready for cooking.
4.
With cooking compartment preheated and ready pilot light on, place pans of food to be
cooked into compartment and shut door.
5.
Set timer to cooking time desired. Cooking cycle may be interrupted at any time by
opening door and resumed again by closing door.
6.
When buzzer sounds, it indicates the end of the cooking cycle and that no more steam is
entering the compartment. Cooking pilot light will go off and ready pilot light will come on.
Buzzer must be shut off by turning the timer to its off position.
CAUTION: An obstructed drain can cause personal injury or
property damage.
Frequently check that the compartment drain and plumbing are free of all obstructions. Never
place food containers, food or food portion bags in the cooking compartment in such a way that
the compartment drain becomes obstructed.
Each compartment is equipped with a removable drain screen. Frequently check the drain
screen for accumulation of food particles. Should food particles accumulate against, or clog the
drain screen, remove it, clean it thoroughly and then replace it in its original position.
