MINIMOTO ATV ELECTRIC POWERED, Instruction Manual

MINIMOTO

™  

ATV

MINIMOTO

™  

ATV

23

TROUBLE SHOOTING:

Problem

Probable Cause

Solution

1) THE KEY IS IN THE “OFF” POSITION

2) YOU ARE SQUEEZING THE BRAKE HANDLE

3) THE BATTERY IS LOW.  

4) THE CIRCUIT BREAKER HAS "POPPED-UP"

5) THE CHARGER IS NOT WORKING 

6) THE BATTERY IS DEAD 

7) THE WIRES ARE LOOSE. 

THE AT

V

 DOES NOT RUN.

1) 

M

O

V

E THE KEY TO THE ON POSITION

2) RELEASE THE BRAKE HANDLE AND TWIST

    THE ACCELERATOR HANDLE.  THE BRAKE

    HANDLE CUTS ALL CURRENT TO THE 

M

OTOR

    WHEN THE BRAKE IS APPLIED.

3) CHARGE THE BATTERY. 

4) WAIT 1

0

 SECONDS AND PRESS THE BLACK

    BUTTON OF THE CIRCUIT BREAKER DOWN TO

    RESET IT

5) CHECK TO SEE IF THE WALL SOCKET IS IN THE

    “ON” POSITION AND THE RED LIGHT ON THE

    CHARGER IS ON WHILE CHARGING. 

6) IF THE BATTERY IS OLD OR HAS BEEN ABUSED

,

    IT WILL NEED TO BE REPLACED 

7) CHECK ALL CONNECTORS.

1) LOW BATTERY 

V

OLTAGE

2) CIRCUIT BREAKER HAS "POPPED-UP"

3) LOOSE CONNECTORS  

THE AT

V

 WAS RUNNING 

BUT IT SUDDENLY STOPPED. 

1) THE ELECTRONIC CIRCUIT WILL AUTO

M

ATICALLY

    DETECT WHEN THE 

V

OLTAGE IS TOO LOW FOR 

    THE AT

V

 TO RUN THE RED “LOW POWER” LED 

    ON THE FRONT CONSOLE WILL CO

M

E ON AND 

    THE POWER WILL SHUT DOWN.  RECHARGE THE 

    BATTERY.  

2) WAIT 1

0

 SECONDS AND PRESS THE BLACK 

    BUTTON ON THE CIRCUIT BREAKER TO RESET.

3) CHECK ALL ELECTRICAL CONNECTIONS

,

    INCLUDING THE ONE THAT ATTACHES TO THE 

    ACCELERATOR PEDAL.

1) THE CHARGER IS STILL CONNECTED

2) 

M

AKE SURE YOU ARE NOT SQUEEZING

    ON THE BRAKE 

THE AT

V

 IS IN “ON” 

M

ODE BUT WHEN I TWIST 

THE ACCELERATOR HANDLE

,

THE BACK WHEELS WON

’

T 

TURN.

1) DISCONNECT THE CHARGER 

2) RE

M

O

V

E PRESSURE FRO

M

 THE BRAKE HANDLE 

    AND TRY AGAIN.

YOU ARE RUNNING THE 

V

EHICLE TOO HARD

,

IN TOO ROUGH TERRAIN

,

 UP TOO STEEP 

AN INCLINE

,

 OR WITH TOO HEA

V

Y A LOAD

I HEAR A “BEEPING” 

SOUND AND THE

AT

V

 SUDDENLY 

STOPPED.

WAIT 1

0

 SECONDS OR UNTIL THE BEEPING 

STOPS TO TRY AGAIN.

THIS IS NOR

M

AL.  THE RIGHT SIDE TIRE 

PRO

V

IDES THE POWER TO THE GROUND 

AND LEFT SIDE PRO

V

IDES THE BRAKING 

ACTION.

ONLY THE RIGHT TIRE 

M

O

V

ES THE 

V

EHICLE.  

THE LEFT TIRE DOESN

’

T 

SEE

M

 TO HA

V

E ANY 

POWER

NO ACTION NECESSARY.

THE CIRCUIT BREAKER 

M

AY 

HA

V

E "POPPED-UP".

THE AT

V

 SUDDENLY 

STOPPED BUT I DON

’

T 

HEAR ANY BUZZERS OR 

SEE THE RED “LOW 

POWER” LED ON.

WAIT 1

0

 SECONDS AND PRESS THE BLACK 

BUTTON IN THE CENTER OF THE CIRCUIT 

BREAKER DOWN.  TRY AGAIN

BROKEN CHAIN 

M

OTOR WILL RUN BUT 

THE AT

V

 DOES NOT 

M

O

V

E.

REPLACE CHAIN