12-42
Simple inspection and service
12. Install the filter case by turning it in the direction
of the arrow . Tighten the filter case using the
special tool and a torque wrench to within the
following torque range.
13. Install the sensor to the filter case.
14. Connect the connector to the sensor.
15. Bleed the fuel system.
P. 13-26
16. Start the engine to test for fuel leakage.
3 Air cleaner check and replacement
CAUTION
Inspect the air cleaner and replace its element at
the specified intervals.
NOTE:
Even if the replacement interval has not elapsed,
clean or replace the element if clogging of the ele-
ment causes a decrease in engine output.
Tightening
torque
30 ± 2 N·m (22 ± 1.5 ft.lbs.,
3 ± 0.2 kgf·m)
WARNING
•
If the fuel filter is tightened to an inappro-
priate torque, fuel could leak and the filter
itself could become damaged, possibly
resulting in a fire and/or explosion.
•
Be careful not to damage the filter case, as
this could cause fuel leakage. When tight-
ening the fuel filter case, be sure to use
the special tool to avoid damaging the
case.
Tightening
torque
5 ± 1 N·m (3.7 ± 0.7 ft.lbs.,
0.5 ± 0.1 kgf·m)
Inspection intervals
Every 10,000 km
(6,000 miles)
Replacement intervals
Every 80,000 km
(48,000 miles) or every
12 months
Z12286
FKFM.book Page 42 Wednesday, January 28, 2009 9:21 AM
Summary of Contents for Fuso FK 2010
