Monark Cardio Care 827 X
13
Ser
vice
Chain 1/2“ x 1/8“
It is strongly recommended to keep the chain
clean. Dirt built up on the chain will cause excess
wear. A chain lubricant and solvent for normal
road bikes may be used.
Check the lubrication and tension of the chain at
regular intervals. In the middle of its free length
the chain should have a minimum play of 5 mm.
See fig: Chain adjustments. When the play in the
chain is about 20 mm (3/4 inch) the chain must
be tightened otherwise it will cause unnormal
wear of the chin and chainwheels. Because of this
it is always recommende to keep the chain play
as little as possible. When the chain has become
so long that it can no longer be tightened with the
chain adjusters it is worn out and shall be repla-
ced with a new one.
Remove left and right frame cover. To adjust the
chain the hub nuts should be loosened. Loose-
ning or tightening the nuts on the chain adjus-
ters will then move the hub and axle forward
or backward. Adjust according to above recom-
mendation. Then tighten the nuts on the hub axle
again. See fig: Chain adjustments.
Loosen the chain adjuster as much as possible.
Dismantle the chainlock and remove the chain.
Put on a new chain and assemble the chain lock.
The spring of the chain lock should be assembled
with the closed end in the movement direction
of the chain. Use a pair of tongs for dismantling
and assembling the spring. See fig: Chain repla-
cement.
Adjust chain adjusters to a chainplay according
to above. Tighten axle nuts firmly. Put on frame
covers again.
NOTE: At assembly the flywheel has to be paral-
lell with the center line of the frame
otherwise the chain and chainwheels makes a lot
of noise and wears out rapidly.
Fig: Chain adjustments
1) Chain adjuster
2) Axel nut
3) Chain play
Fig: Chain replacement
4) Lock spring
5) Movement direction
6) Chain lock
4
6
5
1
3
2
Summary of Contents for cardio care 827 x
