29
Monessen • Natural Blaze Owner’s /Installation Manual • 4619-900 Rev. C • 1/2020
F. Flame Appearance
Flames from the pilot and burner should be visually
checked as soon as the heater is installed.
In addition,
SHULRGLFDOO\FKHFNWKHÀDPHVYLVXDOO\GXULQJRSHUDWLRQ
Check the Pilot Flame (refer to lighting instructions)
7KHSLORWÀDPHPXVWDOZD\VEHSUHVHQWZKHQWKHKHDWHULV
LQRSHUDWLRQ,WVKRXOGMXVWWRXFKWKHWRSRIWKHWKHUPRFRXSOH
WLSIRUQDWXUDO5HIHUWR)LJXUHIRUFRUUHFWSLORWÀDPH
,IWKHSLORWÀDPHGRHVQRWWRXFKWKHWKHUPRFRXSOHWKHQ
WKHPDLQEXUQHUFDQQRWIXQFWLRQUHOLDEO\)LJXUH
for
LQFRUUHFWVKDSHRISLORWÀDPH
FP2272
pilot correct flame
Figure 6.33 - Correct Appearance of Pilot Flame
7KHUPRFRXSOH
IRU1DWXUDO
7KHUPRFRXSOH
IRU/3
Figure 6.34 - Incorrect Appearance of Pilot Flame
7KHUPRFRXSOH
IRU/3
7KHUPRFRXSOH
IRU1DWXUDO
FP2273
pilot bad flame
Figure 6.35 - Correct Appearance of Rear Flames
G. Operating Instructions
$YRLGDQ\GUDIWVWKDWDOWHUEXUQHUÀDPHSDWWHUQV
Do
QRWDOORZIDQVWREORZGLUHFWO\LQWRWKH¿UHSODFH'RQRW
SODFHDEORZHULQVLGHWKHEXUQDUHDRIWKH¿UHER[&HLOLQJ
IDQVPD\FUHDWHGUDIWVWKDWDOWHUÀDPHSDWWHUQV6RRWLQJ
DQGLPSURSHUEXUQLQJZLOOUHVXOW
During manufacturing, fabricating and shipping, various
components of this appliance are treated with certain oils,
¿OPVRUERQGLQJDJHQWV7KHVHFKHPLFDOVDUHQRWKDUP
-
ful, but may produce annoying smoke and smells as they
are burned off during the initial operation of the appliance,
SRVVLEO\FDXVLQJKHDGDFKHVRUH\HRUOXQJLUULWDWLRQ
This
is a normal and temporary occurrence.
7KHLQLWLDOEUHDNLQRSHUDWLRQVKRXOGODVWIRXUKRXUVZLWKWKH
EXUQHUDWWKHKLJKHVWVHWWLQJ3URYLGHPD[LPXPYHQWLODWLRQ
E\RSHQLQJZLQGRZVRUGRRUVWRDOORZRGRUVWRGLVVLSDWH
Any odors remaining after this initial break-in will be slight
DQGZLOOGLVDSSHDUZLWKFRQWLQXHGXVH
7KLVDSSOLDQFHPXVWQRWEHXVHGZLWKJODVVGRRUVLQWKH
FORVHGSRVLWLRQ7KLVFDQOHDGWRSLORWRXWDJHVDQGVHYHUH
VRRWLQJRXWVLGHWKH¿UHSODFH
In normal operation at full rate after 15 minutes, the
IROORZLQJÀDPHDSSHDUDQFHVVKRXOGEHREVHUYHG
%XUQHU ZLOO KDYH D UDQGRP SDWWHUQ RI \HOORZ ÀDPHV DV
VKRZQLQ)LJXUH
.
7KHUHVKRXOGEHJORZLQJHPEHUVRQ
WKHIURQWEXUQHU
127(7KHIURQWÀDPHVDQGHPEHUVZLOO
be an opaque orange color during the burn off time.
CAUTION:
After a 15 minute pre-heat period, observe all
\HOORZÀDPHVWRHQVXUHWKHUHLVQRLPSLQJHPHQWZLWKDQ\
ORJ,IDQ\\HOORZÀDPHLVFRQWDFWLQJDQ\ORJWXUQRIIORJ
VHWDQGDOORZWRFRRO5HPRYHDOOORJVDQGFDUHIXOO\UHLQ
-
VWDOOIROORZLQJORJSODFHPHQWLQVWUXFWLRQVSUHFLVHO\5HOLJKW
EXUQHUDQGFKHFNDJDLQIRULPSLQJHPHQWRIDQ\ÀDPHRQ
ORJ,IÀDPHLPSLQJHPHQWFDQQRWEHHOLPLQDWHGFRQWDFW
\RXULQVWDOOHURUGHDOHUIRUDVVLVWDQFH)ODPHLPSLQJHPHQW
RQORJVPD\FUHDWHVRRWDQGSRVVLEOHSURSHUW\GDPDJH
CAUTION
DO NOT sprinkle volcanic rock on the logs,
around the pilot, or on or near burners. This
may cause sooting. Place volcanic rock only
RQWKHÀRRURIWKH¿UHSODFH
During initial operation of the new heater,
new burning logs and/or rock wool will give
RIIDSDSHUEXUQLQJVPHOODQGRUDQJHÀDPHV
will be present. Simply open the windows for
a few hours to vent the odor.
PLACE THE DECORATIVE ROCK
2SWLRQDOYROFDQLFURFNPD\EHSODFHGDURXQGWKHXQLWRQ
WKHÀRRURIWKH¿UHER[%HVXUHWRDYRLGDQ\DUHDVRQWKH
EXUQHULWVHOI
