31
32
8. TROUBLE SHOOTING
Touch Screen version:
Key Switch Version:
Figure 33
Normal : Solid light
Abnormal : flashing light
Figure 34
Normal : Solid light
Abnormal : flashing light
Self-Diagnostic Warning Light
Flash
Description
Initial check points
1
Battery Low
The batteries are running low.
• Recharge the batteries.
2
Low Battery Fault
The batteries have run out of charge.
• Recharge the batteries.
• Check the battery and associated connections and wiring.
3
High Battery Fault
Battery voltage is too high. This may occur if overcharged and/or traveling
down a long slope.
• If traveling down a slope, reduce your speed to minimize the amount of
regenerative charging.
4
Current limit time-out
or controller overheat
The motor has been exceeding its maximum current rating for too long.
• The scooter may have stalled. Turn the controller off, leave for a few
minutes and turn back on again.
• The motor may be faulty. Check the motor and associated connections
and wiring.
5
Park Brake
Either a park brake release switch is active or the park brake is faulty.
• Check the park brake and associated connections and wiring.
• Ensure any associated switches are in their correct positions.
• Switch to D (drive) position. Turn off the power and turn on again.
6
Drive Inhibit
Either a stop function is active or charger inhibits or OONAPU condition
has occurred.
• Release the stop condition (seat raised etc.)
• Disconnect the battery charger.
• Ensure the throttle is in Neutral when turning the controller on.
• The throttle may require re-calibration.
• The folding/unfolding procedure is uncompleted.
7
Speed Pot
The throttle, speed limit pot. SRW or their associated wiring may be faulty.
• Check the throttle and speed pot and associated connections and
wiring.
8
Motor Voltage
The motor or its associated wiring is faulty.
• Check the motor and associated connections and wiring.
9
Other Error
The controller may have an internal fault.
• Check all connections and wiring.
• If self-diagnostic warning lights with 1 / 2 / 4 / 5 times, please refer to above for solutions (turn off and
restart again or charge the battery). If none of above correct problem, contact your authorized dealer.
• If self-diagnostic warning lights with 3 / 6 / 7 / 8 / 9 times, please contact your authorized dealer directly.
