NOTICE:
When the battery is deeply discharged (for example after left unattended for months
while connected to the radio), it cannot be recovered in all types of chargers. It is best
recovered:
• In a Single-Unit Charger.
• In a Multi-Unit Charger.
D.5
Looking after Your Radio
Never leave your radio or battery in extreme temperatures, for example, behind a windscreen in direct
sunlight.
The radio is submersible (compliant with the IP67 standard) – but only with the battery and the antenna
attached.
To clean your radio, use a moistened or antistatic cloth.
NOTICE:
Elastomer technology materials used for seals in rugged portable radios can age with
time and environmental exposure. Therefore, Motorola Solutions recommends that rugged
radios be checked annually as a preventive measure in order to assure the watertight integrity
of the radio. Motorola Solutions details the disassembly, test, and reassembly procedures along
with necessary test equipment needed to inspect, maintain and troubleshoot radio seals in the
radio’s service manual.
If the radio battery contact area has been submerged in water, dry and clean the radio battery
contacts before attaching a battery to the radio. Otherwise, the water could short-circuit the
radio.
If the radio has been submerged in water, shake the radio well so that any water that may be
trapped inside the speaker grille and microphone port can be removed. Otherwise, the water
will decrease the audio quality of the radio.
Do not disassemble the radio. This could damage radio seals and result in leak paths into the
radio. Any radio maintenance should be performed only by a qualified radio technician.
Do not use solvents to clean your radio as most chemicals may permanently damage the radio
housing and textures.
Do not immerse the radio or battery alone. Radio must have battery, antenna and an accessory
connector seal in place for proper sealing.
If the radio is submerged in water or mud, tap the front of the radio face down. Foreign material
trapped in the speaker grille or microphone port can decrease audio quality. If radio is exposed
to salt water, rinse and wash the radio immediately to reduce risk of corrosion.
D.5.1
Washing the Radio
Prerequisites:
Ensure you have:
• a container of tap water (water height must be at least 2 inches higher than radio height)
• a soft cotton cloth
• a container of 0.5% liquid detergent solution (1 teaspoon of a mild dishwashing liquid detergent to 1
gallon of water or 1 part recommended liquid detergent to 200 parts water; water height must be at
least 2 inches higher than radio height)
• a source of running water
• a towel
MN002041A01-AH
Appendix D: Maintenance
174
