Manual #100-7100
15
Safety Information and
Precautions
/!\ DANGER
Vehicle exhaust gases contain Carbon Monoxide, which is a colorless and odorless lethal gas.
Only run engines in well-ventilated areas and avoid breathing exhaust gases.
Extended breathing of exhaust gases will cause serious injury or death.
/!\ WARNING
Exhaust gases, moving parts, hot surfaces are present during and after the vehicle’s engine is
running. This list is by no means complete. Always pay close attention to the job at hand and
obey all safety procedures.
Read and understand the operator’s manual before using the STEERCLEAN-II Service
system.
When using petroleum products always refer to the MSDS sheets and manufacturer’s
instructions for the proper procedure to handle emergency medical treatment, cleanup,
handling, and storage requirements.
Improper use of the
STEERCLEAN-II
Service System can cause injury.
Spilled service fluid on an engine can ignite.
Avoid exposure to flames, sparks, hot engine parts, and other ignition sources.
Always keep fully charge fire extinguisher nearby. The extinguisher should have a class B
rating and be suitable for gasoline, chemical, and electrical fires.
Cleanup any oil spills immediately.
Dispose of contaminated cleanup material according to governing environmental laws.
Never look directly into the air induction plenum or carburetor throat when the engine is
operating.
Explosion or flame or exposure to flammable liquid and vapors can cause injury.
Flammable liquid (service fluid) can splash out of reservoir when filling. Steering Fluid
temperatures can reach in excess of 350°F, which can cause serious injury to the human body.
Always keep Reservoir Cap secure except when filling reservoir.
Explosion or flame can cause injury.
Power steering systems may maintain residual pressure in connection lines to and from pump
even after the engine has been turned off.
Wear safety goggles.
Wear chemical resistant gloves when connecting or disconnecting fitting and adapters.
Do not swallow or ingest any chemicals.
Summary of Contents for SteerClean-II 500-7100
