500kW Containerized
Diesel Generator Set
Model
Emissions
Standby Rating
Prime Rating
EGC-500C
EPA Certified
60 Hertz
500kW (625kVA)
450kW (562.5kVA)
Standard Features
Cummins Heavy Duty Diesel Engine
4-cycle design, turbocharged, aftercooled, direct injection
Polymide blade cooling fan
Engine coolant heater
Meets EPA Tier 2 emissions standards
Fuel System
800 gallon, single wall fuel tank
Fuel priming system
Fuel/water separators and drip pan
Electric fuel run pump
External fuel fill
30 micron Racor
®
fuel filter system
Alternator
Brushless, 4-pole, synchronous, WYE connection
Class H insulation system conforms to NEMA MG1-22, BS5000,
CSA-C22-2, IEC-34-1 standards for temperature rise
Drip-proof, self-venting, amortisseur windings
Epoxy impregnated windings with tropical insulation for increased
environmental protection and long life
Electronic Voltage Regulator
Electronic automatic voltage regulator provides precise regulation
Separate three-phase excitation for fast recovery from block loads
and motor starting
Full Load Acceptance
Accepts 100% of standby nameplate rating in one step, in compliance
with NFPA, para 5-13.2.6
Generator Control Panel
Basler vibration-isolated controller
Manual or remote engine start/stop
RS485/Modbus communication support
Safety shutdowns
Externally mounted emergency stop switch
Generator mainline circuit breaker, 100% rated, electronically
operated, UL listed
Specially Designed Container
20 ft. ISO container, sound-attenuated, foam-lined for extremely quiet
operation
Solidly mounted battery rack and cooling system
Intregral vibration isolators
Exterior polyurethane coating system provides long life in extreme
operating conditions
Interior DC lights and timer switch
Crankcase filtration system
Critical grade silencer with heat blankets
Warranty
Engine-generator sets are covered by an express written, one-year
limited warranty
(Shown with optional ISO trailer chassis)
EGC500C Rev 0
