PAGE 4 — DCA300SSJU4F2 60 HZ GENERATOR • OPERATION MANUAL — REV. #0 (06/26/18)
NAMEPLATE AND SAFETY LABELS
Safety labels are attached to the generator as shown in
Figure 1. Keep these safety labels clean at all times. When
the safety labels become worn or damaged, contact your
nearest dealer or the Multiquip Parts Dept.
NAMEPLATE/SAFETY INFORMATION
NOTICE
For safety label part numbers, reference parts manual.
．
ｙ
M9503000004
WARNING
MOVING PARTS can cause
severe injury.
DO NOT
operate with doors
open
.
Stop engine before servicing.
M90310000
WARNING
HOT COOLANT
can cause
severe burns.
Do not remove cap if
radiator is hot.
CAUTION
Maximum capacity of lifting
bail is 19,000 lbs.
M55100080
M92010070
WARNING
ARC FLASH AND SHOCK HAZARD
Appropriate PPE Required
Appropriate Personal Protection
Equipment and Tools Required
when working on this equipment.
CAUTION
DO NOT disconnect the Battery Cables
after shutting down the engine for
at least 30 seconds
M90130000
M92010000
WARNING
ELECTRIC SHOCK HAZARD
Do not touch internal wiring
or connections while this
machine is operating.
Turn power off before
servicing.
FRONT VIEW
M9503200004
WARNING
ENGINE EXHAUST can cause
severe injury or death.
Use only in open, well
ventilated areas or
vent exhaust outside.
M92010000
WARNING
ELECTRIC SHOCK HAZARD
Do not touch internal wiring
or connections while this
machine is operating.
Turn power off before
servicing.
This machine stops and starts automatically
and without notice.
CAUTION
M92010060
HIGH VOLTAGE
DANGER
S-2731
WARNING
ELECTRIC SHOCK HAZARD
Do not touch output
terminals while this
machine is operating.
Turn power off before
servicing.
WARNING
ELECTRIC SHOCK HAZARD
Always complete the grounding
path from the ground terminal
on the genset to an external
grounding source.
WARNING
Before connecting this generator to any building’s
electrical system, a licensed electrician must install
an isolation (transfer) switch.
M92010050
Serious injury or death may result without this
transfer switch.
See instruction manual for
details.
Operation of this equipment may create
sparks that can start fires around dry
vegetation.
A spark arrestor may be required.
The operator should contact local fire
agencies for laws or regulations
relating to fire prevention requirements.
M9504200004
WARNING
This unit is designed to contain operating uids only.
The environmental containment is not designed to
control uids from an external source. It is the operator’s
responsibility to monitor uid levels at all times.
DO NOT EXCEED THE RECOMMENDED
MAXIMUM CAPACITY
ENVIRONMENTAL
P/N M91110000
DANGER
Using a generator indoors
CAN KILL YOU IN MINUTES
.
120
V
OFF
GAC-2.2H
POWERED by
Honda Engines
120V
15A
GR PRISE DE
TERRE
AC CIRCUIT BREAKER
INTERRUPTEUR DE
COURANT PRINCIPAL
NEUTRAL BONDED TO FRAME
NEUTRE MIS A LA MASSE A
LA CARCASSE DU MOTEUR
211052
120
V
OFF
GAC-2.2H
POWERED by
Honda Engines
120V
15A
GR PRISE DE
TERRE
AC CIRCUIT BREAKER
INTERRUPTEUR DE
COURANT PRINCIPAL
NEUTRAL BONDED TO FRAME
NEUTRE MIS A LA MASSE A
LA CARCASSE DU MOTEUR
211052
120
V
OFF
GAC-2.2H
POWERED by
Honda Engines
120V
15A
GR PRISE DE
TERRE
AC CIRCUIT BREAKER
INTERRUPTEUR DE
COURANT PRINCIPAL
NEUTRAL BONDED TO FRAME
NEUTRE MIS A LA MASSE A
LA CARCASSE DU MOTEUR
211052
NEVER
use inside a home
or garage. Even if doors
and windows are open.
ONLY use OUTSIDE and
far away from windows,
doors, and vents.
Generator exhaust contains carbon monoxide. This is
a poison gas you cannot see or smell.
Avoid other generator hazards.
READ MANUAL BEFORE USE.
M90320010
MODEL
SERIAL NO.
TOP VIEW
SIDE VIEW
SIDE VIEW
300
Denyo
OFF
W
U
V
OFF
W-U
V-W
U-V
DECREASE
INCREASE
Engine Started
Shutdown
Pre-Alarm
Series 800 Controller
Alarm
Acknowledge
Screen
Change
Program/
Exit
Option
ECU
PSI
OIL PRESS
0
25
50
75
100
°F
WATER TEMP
100
140
180
220
260
°F
FUEL
E
½
F
RPMX10
SPEED
0
120
150
180
210
60
°F
DEF
E
½
F
ＥＣＵ
Integrated Gauge Panel
VOLTS
0
12
18
24
30
%
0
50
100
Check
DEF
Emissions
Failure
Emissions
Failure
Regen
Needed
Regen
Inhibit
Low
Fuel
This machine stops and starts automatically
and without notice.
CAUTION
M92010060
Ensure the “Auto-Off/Reset-Manual” switch is
in the “Off/Reset” position. If it is not, when
the battery cables are connected, the engine
will crank and attempt to start.
CAUTION
M91010040
M911010000
CAUTION
HOT PARTS
can burn skin.
DO NOT
touch until the
machine has sufficiently
cooled.
300
REAR VIEW
OFF
U-V
W-U
V-W
OFF
V
W
U
INCREASE
DECREASE
Series 800 Controller
ECU
Engine Started
Shutdown
Pre-Alarm
Alarm
Acknowledge
Screen
Change
Program
Exit
Option
PSI
OIL PRESS
0
25
50
75
100
°F
WATER TEMP
100
140
180
220
260
°F
FUEL
E
½
F
RPMX10
SPEED
0
120
150
180
210
60
°F
DEF
E
½
F
ＥＣＵ
Integrated Gauge Panel
VOLTS
0
12
18
24
30
%
0
50
100
Check
DEF
Emissions
Failure
Emissions
Failure
Regen
Needed
Regen
Inhibit
Low
Fuel
EXHAUST FLUID ONLY
Filling this tank with
anything other than
DIESEL EXHAUST FLUID
may result in severe
engine damage.
M94110000
No Diesel
D
CAUTION
Figure 1. Nameplate
and Safety Decals
