GA-4.5R/GA-4.5RA A.C. GENERATOR — OPERATION & PARTS MANUAL — REV. #1 (11/27/06) — PAGE 9
GA-4.5R/GA-4.5RA — RULES FOR SAFE OPERATION
■
ALWAYS
be sure the operator is familiar with proper safety
precautions and operation techniques before using generator.
■
NEVER
leave the generator unattended, turn off engine when
unattended.
■
Unauthorized equipment modifications will void all
warranties.
■
ALWAYS
ensure generator is on level ground before use.
■
DO NOT
place hands or fingers inside generator engine
compartment when engine is running.
■
NEVER
run engine without air cleaner. Severe engine damage
may occur.
■
NEVER
change or adjust the engine speed which has been
set at the factory prior to shipping.
■
Removing the engine oil drain plug while
the engine is hot will result in hot oil to gush
out of the oil drain plug, therefore causing
severe scalding to any persons in the general
area of the generator.
Power Cord Safety
■
NEVER
let power cables or cords
lay in wate
r.
■
NEVER
stand in water
while AC power from the generator
is being transfer to a load.
■
NEVER
use a defective or frayed power cable. Check the
cable for cuts in the insulation.
■
NEVER
use a extension cord that is frayed or damaged where
the insulation has been cut.
■
ALWAYS
make certain that proper power or extension cord
has been selected for the job See Table 3.
Grounding Safety
■
ALWAYS
make sure that electrical circuits are properly
grounded
per the
National Electrical Code
(NEC) and
local codes before operating generator. Severe
injury
or
death!
by electrocution can result from operating an
ungrounded generator.
■
ALWAYS
make sure generator is properly grounded to a
suitable earth ground (
GROUND ROD
). See installation
section in this manual.
■
NEVER
use
gas piping
as an electrical ground.
Maintenance Safety
■
NEVER
lubricate components or attempt service on a running
machine.
■
High Temperatures
– Always stop engine and
allow the engine to cool before adding fuel, oil
or performing service and maintenance
functions. Contact with
hot!
components can
cause serious burns.
■
Keep the machinery in proper running condition.
■
Fix damage to the machine immediately and replace any
broken parts immediately.
■
ALWAYS
replace any worn or damaged warning decals.
■
ALWAYS
store equipment properly when it is not being used.
Equipment should be stored in a clean, dry location out of the
reach of children and un-authorized personnel.
■
The electrical voltage required to operate the generator can
cause severe injury or even death through physical contact
with live circuits.
Turn all circuit breakers
OFF
before
performing maintenance on the generator.
■
Dispose of hazardous waste properly. Examples of potentially
hazardous waste are used motor oil, fuel and fuel filters.
■
DO NOT
use food or plastic containers to dispose of
hazardous waste.
■
DO NOT
pour waste, oil or fuel directly onto the ground,
down a drain or into any water source.
Summary of Contents for GA4.5R
