PAGE 12 — DCA-45USI — OPERATION AND PARTS MANUAL (STD) — REV. #2 (04/22/05)
DCA-45USI — RULES FOR SAFE OPERATION
■
NEVER
run engine without air filter. Severe engine damage
may occur.
■
ALWAYS
service air cleaner frequently to prevent engine
malfunction.
■
ALWAYS
disconnect the
negative
battery terminal before
performing service on the generator.
■
ALWAYS
be sure the operator is familiar with proper safety
precautions when operating the generator set.
■
ALWAYS
store equipment properly when not in use.
■
DO NOT
leave the generator running in the
manual mode
unattended.
■
DO NOT
allow unauthorized people to operate this
equipment.
■
ALWAYS
read, understand, and follow procedures in
Operator’s Manual before attempting to operate equipment.
■
Refer to the
Isuzu Engine Owner's Manual
for engine
technical questions or information.
Battery
The battery contains acids that can cause injury to the eyes
and skin. To avoid eye irritation,
always
wear safety glasses.
Use well insulated gloves when picking up the battery. Use
the following guidelines when handling the battery:
1.
DO NOT
drop the battery. There is the possibility of risk
that the battery may explode.
2.
DO NOT
expose the battery to
open flames, sparks, cigarettes
etc. The battery contains
combustible gases and liquids. If
these gases and liquids come in
contact with a flame or spark, an
explosion could occur.
3.
ALWAYS
keep the battery charged. If the battery is not
charged a buildup of combustible gas will occur.
4.
ALWAYS
keep battery charging and cables in good working
condition. Repair or replace all worn cables.
5.
ALWAYS
recharge the battery in an vented air
environment, to avoid risk of a dangerous concentration
of combustible gases.
6. In case the battery liquid (dilute sulfuric acid) comes in
contact with
clothing or skin
, rinse skin or clothing
immediately with plenty of water.
7. In case the battery liquid (dilute sulfuric acid) comes in
contact with your
eyes
, rinse eyes immediately with plenty
of water, then contact the nearest doctor or hospital, and
seek medical attention.
Pay close attention to
ventilation when operating
the generator inside
tunnels and caves. The
engine exhaust contains noxious elements.
Engine exhaust must be routed to a
ventilated area.
DANGER:
DANGER:
DANGER:
DANGER:
DANGER:
Generator Grounding
To guard against electrical shock and possible damage to
the equipment, it is important to provide a good
EARTH
ground.
Article 250 (Grounding) of the
National Electrical Code
(NEC) provides guide lines for proper grounding and specifies
that the cable ground shall be connected to the grounding
system of the building as close to the point of cable entry
as practical.
ALWAYS
be sure to use the ground terminal (green wire)
when connecting a load to the UVWO output terminals.
Transporting
■
ALWAYS
shutdown engine before transporting.
■
Tighten both fuel tank caps securely.
■
If generator is mounted on a trailer, make sure trailer
complies with all local and state safety transportation
laws. See next page “
Towing Safety Precautions
” for
basic towing techniques.
