PAGE 14 — DCA-36SPX— OPERATION AND PARTS MANUAL — REV. #1 (04/14/10)
Check with your local county or state safety towing
regulations, in addition to meeting
Department of
Transportation
(
DOT
)
Safety Towing Regulations
, before
towing your generator.
CAUTION - FOLLOW TOWING REGULATIONS
■
The maximum speed for highway towing is
55 MPH
unless posted otherwise. Recommended off-road towing
is not to exceed
15 MPH
or less depending on type of
terrain.
■
Place
chock blocks
underneath wheel to prevent
rolling
,
while parked.
■
Use the trailer’s swivel jack to adjust the trailer height to
a level position while parked.
■
Avoid sudden stops and starts. This can cause skidding,
or jack-knifing. Smooth, gradual starts and stops will
improve towing.
■
Avoid sharp turns.
■
Trailer should be adjusted to a level position at all times
when towing.
■
Raise and lock trailer wheel stand in up position when
transporting.
■
The maximum speed for highway towing is
55 MPH
unless posted otherwise. Recommended off-road towing
is not to exceed
15 MPH
or less depending on type of
terrain.
■
Place
support blocks underneath the trailer’s bumper to
prevent
tipping
, while parked.
■
Avoid sharp turns to prevent rolling.
■
DO NOT
transport generator with fuel in tank.
Towing and Transporting Safety
To reduce the possibility of an accident while transporting
the generator on public roads, always make sure the trailer
that supports the generator and the towing vehicle are in
good operating condition and both units are mechanically
sound.
The following list of safety precautions should be followed
when towing your generator:
■
ALWAYS
shutdown engine before transporting.
■
Drain fuel from generator fuel tank before towing.
■
If generator is mounted on a trailer, make sure trailer
complies with all local and state safety transportation
laws. Follow the listed
Towing & Transporting Safety
guidelines for basic towing techniques.
■
Make sure the hitch and coupling of the towing vehicle
are rated equal to, or greater than the trailer "gross vehicle
weight rating.”
■
ALWAYS
inspect the hitch and coupling for wear.
NEVER
tow a trailer with defective hitches, couplings, chains etc.
■
Check the tire air pressure on both towing vehicle and
trailer.
Trailer tires should be inflated to 50 psi cold
.
Also check the tire tread wear on both vehicles.
■
ALWAYS
make sure the trailer is equipped with a "
Safety
Chain
".
■
ALWAYS
attach trailer’s safety chains to towing vehicle
properly.
■
ALWAYS
make sure the vehicle and trailer directional,
backup, brake, and trailer lights are connected and
working properly.
■
DOT Requirements include the following:
Connect and test electric brake operation.
Secure portable power cables in cable tray with tie
wraps.
If your generator is trailer mounted, please
read the towing and safety requirements
listed below.
For more saftey tips, see the trailer saftey
guidelines section in this manual.
NOTE
DCA-36SPX — RULES FOR SAFE OPERATION
Summary of Contents for Power WHISPERWATT DCA-36SPX
