PAGE 24 — DCA-400SSK — PARTS AND OPERATION MANUAL (STD)— REV. #3 (09/17/01)
DCA-400SSK — GENERAL INFORMATION
DCA-400SSK FAMILIARIZATION
Generator
The MQ Power Model DCA-400SSK is a 320 kW gener
gener
gener
gener
generator
ator
ator
ator
ator
that is designed as a high quality portable (requires a trailer
for transport) power source for telecom sites, lighting
facilities, power tools, submersible pumps and other
industrial and construction machinery.
Engine Control Panel
The “Engine Control Panel” is provided with the following:
z
Auto/Start/Stop Controller (S/N 3696510~)
z
Tachometer
z
Water Temperature Gauge
z
Oil Pressure Gauge
z
Charging Ammeter Gauge
z
Engine Warning Lamp Module
z
Engine Speed Switch (S/N3701667~)
z
Pre-Heat Button
z
Pre-Heat Lamp
z
Emergency Stop Button
z
Battery Switch
z
Starter Switch (Up to S/N3696509)
Generator Control Panel
The “Generator Control Panel” is provided with the following:
z
Output Voltage Adjustment Knob
z
Frequency Meter (Hz)
z
AC Ammeter (Amps)
z
AC Voltmeter (Volts)
z
Ammeter Change-Over Switch
z
Voltmeter Change-Over Switch
z
Panel Light
z
Auto On/Off Engine Controller
z
Panel Light Switch
z
Pilot Lamp
Output Terminal Panel
The “Output Terminal Panel” is provided with the following:
z
Three120/240V output receptacles, 50 amp
z
Two 120V receptacles, 20 amp
z
3 Circuit Breakers 240V @50 amps
z
2 GFCI Circuit Breakers 125V@ 20amps
Control Box
The “Control Box” is provided with the following:
z
Main Circuit Breaker 1060 amps
z
Over-Current Relay
z
High Idle Adjust Trimmer
z
Current Transformer
z
Automatic Voltage Regulator
Open Delta Excitation System
The DCA-400SSK generator is equipped with the state of
the art "Open-Delta
Open-Delta
Open-Delta
Open-Delta
Open-Delta" excitation system. The open delta
system consist of an electrically independent winding wound
among stationary windings of the AC output section.
There are four leads: A, B, C and D. During light loads, the
power to the A
A
A
A
Automatic
utomatic
utomatic
utomatic
utomatic V
V
V
V
Voltage Regulator
oltage Regulator
oltage Regulator
oltage Regulator
oltage Regulator (AVR) is supplied
from the leads parallel connections of B&C. When loads
increase, the AVR switches and accepts power from leads
A&D. The output of leads A&D increase proportionally with
load.
This of adding the voltages to each phase provides
better voltage response during heavy loads.
The connections of the AVR to the AC output windings are
for sensing only. No power is required from these windings.
The open-delta design provides virtually unlimited excitation
current, offering maximum motor starting capabilities. The
excitation does not have a "fixed ceiling
fixed ceiling
fixed ceiling
fixed ceiling
fixed ceiling" and responds
according the demands of the required load.
Engine Controller Alarm System
The DCA-400SSK generator is equipped with various alarms
and LED status indicators. These alarms and status indicators
are provided to add safety to the generator when operating
under normal conditions. The DCA-400SSK generator is
designed to shutdown in the event of low oil, high coolant
temperature, low battery and other operation conditions that
may cause severe damage to the generator.
Summary of Contents for Power WHISPERWATT DCA-400SSK
