MULTIQUIP QP4TH, Operation And Parts Manual

QP4TH TRASH PUMP • OPERATION AND PARTS MANUAL — REV. #3 (01/29/14) — PAGE 9

SAFETY INFORMATION

„

Store fuel in appropriate containers, in well-ventilated 

areas and away from sparks and fl ames.

„

NEVER use fuel as a cleaning agent.

„

DO NOT smoke around or near the 

equipment. Fire or explosion could result 

from fuel vapors or if fuel is spilled on a 

hot engine.

BATTERY SAFETY (ELECTRIC START ONLY)

  DANGER

„

DO NOT drop the battery. There is a possibility that the 

battery will explode.

„

DO NOT expose the battery to open fl ames, 

sparks, cigarettes, etc. The battery contains 

combustible gases and liquids. If these 

gases and liquids come into contact with a 

fl ame or spark, an explosion could occur.

  WARNING

„

ALWAYS  wear safety glasses when 

handling the battery to avoid eye irritation. 

The battery contains acids that can cause 

injury to the eyes and skin.

„

Use well-insulated gloves when picking up 

the battery.

„

ALWAYS keep the battery charged. If the battery is not 

charged, combustible gas will build up.

„

DO NOT charge battery if frozen. Battery can explode. 

When frozen, warm the battery to at least 61°F (16°C).

„

ALWAYS recharge the battery in a well-ventilated 

environment to avoid the risk of a dangerous concentration 

of combustible gases.

„

If the battery liquid (dilute sulfuric acid) 

comes into contact with 

clothing or skin, 

rinse skin or clothing immediately with 

plenty of water.

„

If the battery liquid (dilute sulfuric acid) comes into 

contact with 

eyes, rinse eyes immediately with plenty 

of water and contact the nearest doctor or hospital to 

seek medical attention.

  CAUTION

„

ALWAYS disconnect the NEGATIVE battery terminal 

before performing service on the equipment.

„

ALWAYS keep battery cables in good working condition. 

Repair or replace all worn cables.

TRANSPORTING SAFETY

  CAUTION

„

NEVER allow any person or animal to stand underneath 

the equipment while lifting.

  NOTICE

„

Before lifting, make sure that the equipment parts (hook 

and vibration insulator) are not damaged and screws are 

not loose or missing.

„

Always make sure crane or lifting device has been 

properly secured to the lifting bail (hook) of the 

equipment.

„

ALWAYS shutdown engine before transporting.

„

NEVER lift the equipment while the engine is running.

„

Tighten fuel tank cap securely and close fuel cock to 

prevent fuel from spilling.

„

Use adequate lifting cable (wire or rope) of suffi cient 

strength.

„

Use one point suspension hook and lift straight upwards.

„

DO NOT lift machine to unnecessary heights.

„

ALWAYS tie down equipment during transport by 

securing the equipment with rope.