MagnaTrack S
the anchor plate located on the side of the vehicle,
see
.
4
Reverse the vehicle into its parking space.
5.2 Disconnection
1
Make sure the hose is connected to the exhaust
pipe and that it is firmly fastened to the anchor
plate on the vehicle’s side.
2
Start the fan and open the station door. Drive the
vehicle straight out from the garage with a maxim-
um speed of 15 km/h (10 mph). The hose automat-
ically disconnects when the vehicle is driven out.
If the magnet does not disconnect as it should, it will
be pulled off the anchor plate by the hose without
damage to the system. This may cause the nozzle to
sway more than normally. Approx. 800 N (176 lbs) is
required to pull the magnet off the anchor plate.
A manual disconnection from the anchor plate is pos-
sible with a switch on the electromagnet unit.
6 Maintenance
WARNING! Risk of personal injury
A dust filter mask should be used during ser-
vice and repairs inside the system, especially
when working on the nozzle and hose.
NOTE!
The service intervals in this chapter are based
on the unit being professionally maintained.
6.1 Check points
6.1.1 Check the following points once a
month
• The nozzle's internal contact surface. Clean with a
dry cloth when necessary.
• The electromagnetic operation. Check the attach-
ment with the connector and use a dry cloth to clean
the magnet and anchor plate on the vehicle when
necessary.
• Disconnection position. The extraction hose should
disconnect from the exhaust pipe immediately be-
fore the station door opening at normal speed, not
more than 15 km/h (10 mph). Adjust the disconnec-
tion position by moving the disconnection magnet
on the front rail, see
• Make sure that the hose lifts up properly. If neces-
sary, adjust the elastic cord length in the vertical
hose.
6.1.2 Check the following points once a year
or when needed
• Check that the trolley moves easily in the whole
length of the rail.
• Check the mounting chains with bolts.
• The hose's carriers.
• The hoses.
• Electrical installation, see
EN
21
Summary of Contents for MagnaTrack S
