WARNING
Do not try lighting this appliance without reading the
“LIGHTING INSTRUCTIONS” section of this manual.
CAUTION: Beware of Flashback
CAUTION:
Spiders and small insects occasionally
spin webs or make nest in the grill
burner tubes during transit and
warehousing. These webs can lead
to gas flow obstruction, which could
result in a fire in and around burner
tubes. This type of fire is known as
“FLASH-BACK” and can cause serious damage to your
grill and create an unsafe operating condition for the
user.
Although an obstructed burner tube is not the only cause
of “FLASH-BACK”, it is the most common cause.
To reduce the chance of “FLASH-BACK”, you must
clean the burner tubes before assembling your grill, and
at least once a month in late summer or early fall when
spiders are most active. Also perform this burner tube
cleaning procedure if your grill has not been used for an
extended period of time. A clogged tube can be lead to a
fire beneath the grill.
Grill Installation Codes
Check your local building codes for the proper method of
installation. In the absence of local codes, this unit
should be installed in accordance with the National Fuel
Gas Code, ANSI Z223.1/NFPA 54,Storage and Handling
of Liquefied Petroleum Gases, ANSI /NFPA B149.2 or
CSA B149.1 Natural Gas and Propane Installation Code,
and the National Electrical Code, ANSI/NFPA 70.
Correct LP Gas Tank Use
LP gas grill models are designed for use with a standard
20 lb. Liquid Propane Gas tank, not included with grill.
Never
connect your gas grill to an LP gas tank that
exceeds this capacity.
NOTE
: The normal flow of gas through the regulator and
hose assembly can create a humming noise. A low
volume of noise is perfectly normal and will not interfere
with operation of the grill. If humming noise is loud and
excessive you may need to purge air from the gas line
or reset the regulator excess gas flow device. This
purging procedure should be done every time a new LP
gas tank is connected to your grill.
Visually check the burner flames prior to
each use. The flames should look like
this picture. If they do not, refer to the
burner maintenance part of this manual.
Liquid propane
flame
TESTED IN ACCORDANCE WITH ANSI Z21.58-
2018 •
CSA 1.6-2018 STANDARD FOR OUTDOOR COOKING
GAS APPLIANCE. THIS GRILL IS FOR OUTDOOR
USE ONLY.
Safety Instructions
3
DANGER
If you smell gas:
•
Shut off gas to the appliance.
•
Extinguish any open flame.
•
If odor continues, keep away from
the appliance and immediately call
your gas supplier or your fire
department.
WARNING
•
Do not store or use gasoline or
other flammable liquids or vapors
in the vicinity of this or any other
appliance.
•
An LP cylinder not connected for
use shall not be stored in the
vicinity of this or any other
appliance.
Failure to comply with these instructions could result in a fire or explosion that could cause serious
bodily injury, death, or property damage.
Combustion by products produced when using this product contain chemicals known to the States of
California to cause cancer, birth defects, or other reproductive harm.
Your grill will be very hot. Never lean over the cooking area while using your grill. Do not touch cooking
surfaces, grill housing or any other grill parts while the grill is in operation, or until the gas grill has cooled
down after use.
