8
11.
Make sure that all parts are properly tightened before you use the exercise cycle.
Note: After assembly is
completed, some extra parts may be left over. Place a mat beneath the exercise cycle to protect the floor.
10.Identify the Left Pedal (22), which is marked with an
“L.” Using an adjustable wrench,
firmly tighten
the
Left Pedal
counterclockwise
into the Left Crank Arm
(24). Tighten the Right Pedal (not shown)
clockwise
into the Right Crank Arm (not shown).
Important:
Tighten both Pedals as firmly as possible. After
using the exercise cycle for one week, retighten the
Pedals.
Adjust the Left Pedal Strap (25) to the desired position,
and press the end of the Left Pedal Strap onto the tab
on the Left Pedal (22). Adjust the Right Pedal Strap
(not shown) in the same way.
10
25
22
24
Tab
8. While another person holds the Console (4) near the
Handlebar (3), connect the Upper Wire Harness (42)
to the wire harness on the Console, and connect the
Pulse Wire (75) to the pulse wire on the Console.
Insert the excess wiring into the Upright (2).
Attach the Console (4) to the Handlebar (3) with four
M4 x 16mm Round Head Screws (80).
Be careful to
avoid pinching the wires and wire harnesses.
9. Thread an M6 x 8mm Button Screw (59) into the front
hole in the Seat Post (8). Next, orient the Seat
Carriage (11) as shown, and slide it onto the Seat
Post. Thread the other M6 x 8mm Button Screw into
the rear hole in the Seat Post.
Next, attach the Seat (9) to the Seat Carriage (11) with
four M8 Nylon Locknuts (79) and four M8 Split
Washers (55). (Note: The Nylon Locknuts and the Split
Washers may be pre-attached to the Seat.) Thread the
Seat Knob (10) clockwise into the right side of the Seat
Carriage until it is tight.
75
4
80
3
42
8
7. The Console (4) requires four “D” batteries (not includ-
ed); alkaline batteries are recommended. Remove the
battery cover from the bottom of the Console. Next,
insert four batteries into the battery compartment;
make sure that the batteries are oriented as shown
by the diagram inside the battery compartment.
Reattach the battery cover.
7
4
Batteries
Battery
Cover
9
10
8
11
55
55
79
9
59
Front
Hole
79
2
