3
1
4
Installation
3‐8
P/N 213828_11
2014 Nordson Corporation
VersaBlue_PPA
NOTE:
For units with recirculation hoses: do not mistake recirculation hoses
for feed hoses.
CAUTION:
Nordson melters are generally subjected to extensive testing
prior to shipment. Residue of the test material, similar to adhesive, may still
be found in the hose connection.
If cold material can be found in the hose connection, the components (3, 4)
must be heated until the material softens (approx. 70 °C/158 °F, depending
on the material).
ATTENTION:
Hot! Risk of burns. Wear heat-protective gloves.
2. Heat the melter and hose until the material softens.
3. Connect the hoses in the order of the numbers on the manifold. This
prevents the creation of dead space that would otherwise result from
unused connections.
Close unused hose connections with Nordson port plugs.
Disconnecting
ATTENTION:
System and material pressurized. Relieve bulk melter
pressure before disconnecting pressurized components (e.g. hoses,
pressure sensors). Failure to observe can result in serious burns.
Relieving Adhesive Pressure
1. Switch off the motor(s) (Refer to section
Operation
).
2. Place a container under the nozzle(s) of the applicator / assembly
handgun.
3. Activate the solenoid valve(s) electrically or manually, or pull the trigger of
the assembly handgun. Repeat this procedure until no more material
flows out.
4. Properly dispose of material according to local regulations.
Summary of Contents for VersaBlue VA
