13
Diese Montage-, Bedienungs- und Wartungsanleitung ist während der gesamten Nutzungsdauer aufzubewahren!
D
Wartungs- und Sicherheitsprüfung
NovoPorta Premio Türen mit Brandschutz-
ausstattung sind selbstschließende, sicher-
heitstechnische Anlagen, deren Funktions-
fähigkeit immer gewährleistet sein muss.
Der Bauherr / Betreiber ist für die Funkti-
onsfähigkeit der Brandschutztüren verant-
wortlich. Darum empfehlen wir, dass ein
entsprechender Wartungsvertrag zwischen
dem Bauherrn / Betreiber und einem auto-
risierten Fachbetrieb abgeschlossen wird.
Wartungsarbeiten sollten nach 50.000 Be-
tätigungen oder einmal im Jahr bzw. bei
Störungen durchgeführt werden.
Der Ersatz mangelhafter Teile (Beschlag,
Zubehör, Glas) darf nur von einem autori-
sierten Fachbetrieb durchgeführt werden.
Bei der Durchführung der Wartungsarbei-
ten müssen die Vorgaben der bauaufsichtli-
chen Zulassung (bei Rauchschutztüren des
Prüfberichts / Zeugnisses) beachtet werden.
1. Reinigen der Elemente, vor allem die
beweglichen Teile und Funk tionszonen
2. Überprüfen aller Funktionen
– Selbsttätiges Schließen (Schließ-
folgeregelung, Schließkraft)
– Antipanikfunktion
– Feststellanlagen (siehe Richtlinien
vom DIBt)
– Schwellendichtung oder absenkbare
Dichtung (Auslösung, Verpressung
der Dichtung)
– Gängigkeit der Beschlagteile (Schlös-
ser, Elektrotüröffner, Türdrücker),
Fetten der beweglichen Teile
–
Die Lagerbuchse der Türbänder ist
aus absolut wartungsfreiem, teflon-
haltigem Kunststoff. Keinesfalls
schmieren!
– Spalt zwischen Flügel und Blend-
rahmen (eventuell Türbänder nach-
stellen)
– Sicherungsbolzen im Bandbereich
auf festen Sitz kontrollieren
Hinweis:
Als Ersatz von beschädigten
oder funktionslos gewordenen Teilen
(Beschlag, Zubehör, Gummidichtung,
Glas, usw.) dürfen nur die Original-
Ersatzteile verwendet werden.
3. Überprüfen der Dichtungen zwischen
– Flügelrahmen und Blendrahmen
– Glas und Flügelrahmen
– Blendrahmen und Baukörper
– ggf. Nachbessern oder Auswechseln
der Dichtstoffe bzw. Dichtprofile
– ggf. beschädigte Dichtbänder mit PVC
(im Brandfall aufschäumende Bau-
stoffe) austauschen
4. Überprüfen des Glases durch Sicht-
kontrolle auf Einläufe und Sprünge
Wartungs- und Sicherheitsprüfung
Die Wartungsintervalle sind nach der Nutzungshäufigkeit, jedoch mindestens einmal pro Jahr durchzuführen. Die nachfolgenden
Wartungsanweisungen stellen den Mindestumfang der durchzuführenden Wartungsarbeiten dar.
Bauteil
Ausführung
Bänder
3-D-Objektbänder:
3-D-Objektbänder sind wartungsfrei. Keinesfalls schmieren/fetten!
Alle anderen Bänder:
Bandbolzen demontieren, reinigen und einfetten.
Druckkugel lager
Bei Schäden (gebrochene Ringe, defekte Abdeckung, gebrochene oder verlorene Kugeln)
Lager gegen ein neues austauschen.
Türschließer
Funktion prüfen:
Tür muss aus jeder Stellung schließen (Falle muss eingreifen).
Einstellen:
gemäß Türschließermontageanleitung. Federband muss, falls vorhanden, leicht
vorgespannt sein.
Drücker garnitur
Funktion prüfen:
Drücker muss durch Federkraft des Schlosses im Ruhezustand waage-
recht stehen. Befestigung überprüfen.
Schloss (Gangflügel)
Funktion Falle:
muss ca. 6 mm in Schließblech im Standflügel ein greifen (Fallenfederkraft
2,5 N – 4,0 N).
Funktion Riegel:
muss zweitourig ausschließen.
Schnapp-Falztreib riegel (Standflügel)
Funktion prüfen:
muss min. 6 mm ins Querteil der Zarge eingreifen.
Griff des Umlenkgetriebes muss durch Federkraft immer senkrecht stehen.
Riegelkopf in seiner Führung leicht einfetten.
Sicherungs bolzen
Die Bolzen müssen ausreichend in die Zargenaussparung eingreifen.
Schließfolgeregler
(nur bei zwei flügeligen Türen)
Funktion prüfen:
Der Ausstellarm muss beim Öffnen der Türflügel durch Federkraft zur
eingestellten Endlage ausschwenken. Gangflügel muss beim Schließen mit seinem An-
schlagwinkel genau auf den Ausstellarm auftreffen und stehen bleiben. Der Standflügel
muss nun beim Schließen mit dem Anschlagwinkel den Ausstellarm mitnehmen und den
Gangflügel somit wieder freigeben, so dass sich auch dieser selbsttätig schließen kann.
Beide Flügel müssen nun verriegelt sein.
Einstellen:
Gelenk am Fuß des Reglers leicht einfetten. Bei lahmer Feder Gerät austau-
schen.
Bei integrierter Schließfolgeregelung siehe Wartungsanleitung des Türschließers.
Aufschäumender Baustoff
Überprüfen, ob die Streifen Schädigungen aufweisen. Wenn die Streifen lose oder beschä-
digt sind, unbedingt erneuern.
Summary of Contents for NovoPorta Premio E-S-1
