DMTA-10045-01EN, Rev. E, August 2016
Maintenance and Troubleshooting
207
8. Maintenance and Troubleshooting
The BondMaster 600 composite bond tester is an industrial quality electronic
instrument that requires very little maintenance. Most troubleshooting and
maintenance procedures may be performed by the user. However, if problems persist,
contact Olympus for technical assistance.
8.1
Lithium-Ion Battery
Under normal operating conditions, the BondMaster 600 can operate on battery
power for at least 8 hours between charges (for standard operation). As the battery
power depletes, the percentage of remaining battery life is displayed on the battery
indicator. When the battery charge becomes insufficient, the BondMaster 600
automatically turns off to prevent damage to the battery. Recharge the battery using
the charger and power cord supplied with the instrument.
Charging the Battery
The charger/adaptor indicator light (battery charge LED) illuminates red while the
battery is charging, and turns green when the battery is fully charged. The
approximate recharge time is two hours to three hours.
Replacing the Battery
Rechargeable batteries lose their ability to hold a full charge after several hundred
recharges. For more information on installing and replacing the battery, see “Lithium-
Ion Battery” on page 34 and “Alkaline Batteries” on page 35.
Summary of Contents for BondMaster 600
