SECTION 6 - JLG CONTROL SYSTEM
6-54
– JLG Lift –
3121659
FLOW CONTROL VALVE – OPEN
CIRCUIT
33314 The UGM detects an open circuit at this output
The UGM shall suspend Flow
Control and revert to Open
Current loop control for Flow
Control;
The UGM shall limit Tele-
scope, Jib Lift Up, Jib Lift
Down (400S, 450AJ), Plat-
form Rotate and Platform
Level to Creep speed after
controls initialized
The UGM no longer detects open circuit;
Full speed Telescope, Jib Lift Up, Jib Lift
Down (400S, 450AJ), Platform Rotate and
Platform Level permitted after controls are
initialized
FLOW CONTROL VALVE –
SHORT TO BATTERY
33315 The UGM detects a short to battery at this output
The UGM shall prohibit Flow
Control, Telescope, Jib Lift Up
(permitted if operating in
Auxiliary Power/Emergency
Descent mode), Jib Lift Down
(permitted if operating in
Auxiliary Power/Emergency
Descent mode)(400S,
450AJ), Platform Rotate and
Platform Level
Power Cycled
FLOW CONTROL VALVE –
SHORT TO GROUND
33316 The UGM detects a short to ground at this output
The UGM shall prohibit Flow
Control, Telescope, Jib Lift Up,
Jib Lift Down (400S, 450AJ),
Platform Rotate and Platform
Level
Power Cycled
DRIVE FORWARD VALVE –
OPEN CIRCUIT
33317
The UGM detects an open circuit at this output
The UGM shall suspend Drive
Forward and Reverse com-
mand and revert to Open Cur-
rent loop control for Drive;
The UGM shall limit Drive For-
ward and Reverse to Creep
speed after controls initial-
ized
The UGM no longer detects open circuit;
Full speed Drive Forward and Reverse per-
mitted after controls are initialized
DRIVE VALVES – SHORT TO BAT-
TERY
33318 The UGM detects a short to battery at either the Drive Forward
or Drive Reverse valve.
The UGM shall prohibit Drive
Forward and Reverse;
The UGM shall open the Drive
Current Feedback low side
FET
Power Cycled
DRIVE FORWARD VALVE –
SHORT TO GROUND
33319 The UGM detects a short to ground at this output
The UGM shall prohibit Drive
Forward and Reverse
Power Cycled
DRIVE REVERSE VALVE – OPEN
CIRCUIT
33320 The UGM detects an open circuit at this output
The UGM shall suspend Drive
Forward and Reverse com-
mand and revert to Open Cur-
rent loop control for Drive;
The UGM shall limit Drive For-
ward and Reverse to Creep
speed after controls initial-
ized
The UGM no longer detects open circuit;
Full speed Drive Forward and Reverse per-
mitted after controls are initialized
DRIVE REVERSE VALVE – SHORT
TO GROUND
33322 The UGM detects a short to ground at this output
The UGM shall prohibit Drive
Forward and Reverse
Power Cycled
Table 6-5. Diagnostic Trouble Code Chart
Help Message
DTC
Fault Condition/Trigger
(For configurable items, fault applies only if
configured. All listed conditions to be met unless
stated otherwise)
Required Control
Response or State
Assignment
Conditions Required for Movement
and/or to Clear Fault
Summary of Contents for JLG 450AJ
