- 8 -
WARNING
: Batteries emit hydrogen and oxygen gas.
•
Keep sparks and open flame away.
•
Do not smoke near the machine.
•
Charge batteries in a well-ventilated area with the battery compartment open.
WARNING
: Do not wear jewelry when working near moving or electrical components.
CHARGING
WARNING
: Do not plug in the charger cable if wall cord or battery harness is damaged.
NOTE
:
Do not use an extension cord with the battery charger. This will void the charger warranty.
NOTE
:
Ensure battery charging and storage locations comply with OSHA and any governing agencies’ standards based on
your particular location and application.
The charger status LED’s (used to indicate the charger’s status while plugged in) can be viewed through the view window located on
the vertical kick panel below the seat.
LED INDICATION
MEANING
GREEN flashing (2 seconds) Charger is set for AGM batteries
YELLOW flashing (continuous) Unsuitable battery connected or output short circuit
RED flashing (2 seconds)
Charger is set for Lead Acid batteries
RED flashing (continuous)
Safety timer exceeded or internal short circuit
Solid GREEN
The unit is fully charged
Solid YELLOW
Phase 2 of charging is in progress
Solid RED
Charging cycle has begun
NOTE
:
Seat assembly must remain open while charging to prevent damage to the charger power cord.
CHARGER SETTINGS
SW1
DP2
DP1
APPLICATION
OFF
ON
LEAD-ACID BATTERIES
OFF
OFF
AGM FULLRIVER
ON
OFF
AGM DISCOVERY
ON
ON
GEL
SW2
DP2
DP1
CHARING CURRENT
ON
ON
15A
ON
OFF
20A
OFF
ON
25A
OFF
OFF
25A
SW1: Sets the current profile of the charger to the particular battery that is installed.
SW2: Set the current level of the charger based on the
amp-hour rating for the particular batteries installed.
CHARGING CURRENT
BATTERY AMP HOUR RANGE (5h) BATTERY AMP HOUR RANGE (20h)
15A
100-150 Ah
130-180 Ah
20A
120-195 Ah
150-240 Ah
25A
180-258 Ah
220-315 Ah
ON-BOARD CHARGING
Summary of Contents for S-20
