Read these safety warnings before operation.
1.
Stay alert. Watch what you are doing and use common sense when operating the hose reel.
2.
Do not use the hose reel while tired or under the influence of drugs, alcohol, or medication. Any inattention while operating the hose reel increases
the risk of injury to persons.
3.
Dress properly. Do not wear loose clothing or jewelry. Contain long hair. Keep hair, clothing, and gloves away from moving parts. Loose clothes, jewelry, or
long hair increases the risk of injury to persons as a result of being caught in moving parts.
4.
Do not overreach. Keep proper footing and balance at all times. Proper footing and balance enables better control of the hose reel in unexpected
situations.
5.
Disconnect the hose reel from the air source before making any adjustments, changing accessories, or storing the hose reel. Such preventive safety
measures reduce the risk of starting the hose reel or tool unintentionally.
6.
Store the hose reel when it is idle out of reach of children and other untrained persons. A hose reel is dangerous in the hands of untrained users.
7.
Use only accessories that are identified by the manufacturer for the specific hose reel model. Use of an accessory not intended for use with the
specific hose reel model, increases the risk of injury to persons.
8.
Hose reel service must be performed only by qualified repair personnel.
9.
When servicing a hose reel, use only authorized, identical replacement parts.
10. Never connect to an air source that is capable of exceeding 200 psi. Over pressurizing the hose reel may cause bursting, abnormal operation,
breakage of the hose reel or serious injury to persons.
11. Use only clean, dry, regulated compressed air at the rated pressure or within the rated pressure range as marked on the hose reel.
12. Always verify prior to using the hose reel that the air source has been adjusted to the rated air pressure or within the rated air-pressure range.
13. Never use oxygen, carbon dioxide, combustible gases or any bottled gas as an air source for the hose reel. Such gases are capable of explosion and
serious injury to persons.
14. The warnings and precautions discussed in this manual cannot cover all possible conditions and situations that may occur. It must be understood by
the operator that common sense and caution are factors which cannot be built into this product, but must be supplied by the operator.
15. Obey the manual for the air hose reel and air compressor used with this hose reel.
16. Install an in-line shutoff valve to allow immediate control over the air supply in an emergency, even if a hose is ruptured.
17.
WARNING:
The brass components of this product contain lead, a chemical known to the State of California to cause birth defects or other
reproductive harm.
SPECIFICATIONS
Maximum Working Pressure .................................................250 PSI
Air Outlet ...................................................Brass 1/4 in. Female NPT
Air Inlet .....................................................Brass 1/4 in. Female NPT
Capacity ......................................................................50 ft. x 3/8 in.
Specifications are subject to change without notice
IMPORTANT SAFETY INFORMATION
2
Contents:
Hose Reel
Instruction Manual
Handle & Bolt
Make sure all parts listed above are enclosed.
Tools Needed for Assembly:
Hex head screwdriver and adjustable wrench and thread sealant.
Mounting Holes
Handle
Reel Flange
Swivel Coupler
Outlet to
Hose
